JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE) ›› 2018, Vol. 48 ›› Issue (4): 94-101.doi: 10.6040/j.issn.1672-3961.0.2017.617

Previous Articles     Next Articles

Fault diagnosis of electromagnetic coil in active magnetic bearing based on current characteristics

CHENG Xin1,2, ZHANG Lin1, HU Yefa1,2, CHEN Qiang1, LIANG Dian1   

  1. 1. School of Mechanical and Electronic Engineering, Wuhan University of Technology, Wuhan 430070, Hubei, China;
    2. Hubei Magnetic Suspension Engineering Technology Research Center, Wuhan 430070, Hubei, China
  • Received:2017-09-14 Online:2018-08-20 Published:2017-09-14

PDF (PC)

319

Abstract: Magnetic bearings had been widely used for its excellent performance,but the fault of electromagnetic coil might cause the rotor to lose control and cause serious consequences. A on-line fault diagnosis method of electromagnetic coil formagnetic bearings was proposed through the establishment of mathematical model of digital switching power amplifier output current, the current output characteristic was obtained, and the influence of the coil fault on the output current variation rate was theoretically analyzed. A Matlab/Simulink model was established under the two state modulation,the simulation results demonstrated the theoretical feasibility of the method. A fault diagnosis scheme and related algorithm based on current oversampling was designed.Then a digital switching power amplifier test platform based on digital signal processor(DSP)was built, and the on-line detection experiment of related coil faults was carried out. The experimental results demonstrated the effectiveness of the method discussed in this paper.

Key words: magnetic bearings, switching power amplifier, on-line, current variation rate, fault diagnosis, effectiveness

CLC Number: 

  • TH133.3
[1] SCHWEITZER G, BLEULER H, TRAXLER A. Active magnetic bearings: basics, properties and applications of active magnetc bearings[M]. Zurich, Swizerland: vdf Hochschulverlag AG an der ETH Zurich, 1994.
[2] SCHWEITZER G, MASLEN E H. Magnetic bearings: theory, design, and application to rotating machinery[M]. Berlin, Germany: Springer, 2009.
[3] MASLEN E H, MEEKER D C. Fault tolerance of magnetic bearings by generalized bias current linearization[J]. IEEE Transactions on Magnetics, 1995, 31(3): 2304-2314.
[4] CHENG X, LIU H, SONG S, et al. Reconfiguration of tightly-coupled redundant supporting structure in active magnetic bearings under the failures of electromagnetic actuators[J].International Journal of Applied Electromagnetics & Mechanics, 2017, 54(3):1-12.
[5] CHENG X, CHEN Q, ZENG H, et al. Reconfiguration rules for loosely-coupled redundant supporting structure in radial magnetic bearings[J]. International Journal of Applied Electromagnetics & Mechanics, 2016, 51(2):91-106.
[6] 汲胜昌, 刘味果, 李彦明,等. 振动法用于在线监测电力变压器绕组及铁心状况的可行性研究[J]. 高压电器, 2001, 37(5):4-7. JI Shengchang, LIU Weiguo, LI Yanming, et al. Feasibility of vibration analysis method in application to on-line monitoring of the core and the winding of power transformer[J]. High Voltage Apparatus, 2001, 37(5): 4-7.
[7] 李永刚, 李和明, 赵华. 汽轮发电机转子绕组匝间短路故障诊断新判据[J]. 中国电机工程学报, 2003, 23(6):112-116. LI Yonggang, LI Heming, ZHAO Hua. The new criterion on interturn short-circuit fault diagnose of steam turbine generator rotor windings[J]. Proceedings of the CSEE, 2003, 23(6):112-116.
[8] BACHSCHMID N, PENNACCHI P, VANIA A. Identification of multiple faults in rotor systems[J]. Journal of Sound & Vibration, 2002, 254(2):327-366.
[9] CADE I S, KEOGH P S, SAHINKAYA M N. Fault identification in rotor/magnetic bearing systems using discrete time wavelet coefficients[J]. IEEE/ASME Transactions on Mechatronics, 2005, 10(6):648-657.
[10] 陈小玄,罗大庸,单勇腾.小波分析在转子绕组匝间短路故障诊断中的应用[J]. 电机与控制学报, 2007, 11(2):143-147. CHEN Xiaoxuan, LUO Dayong, SHAN Yongteng. Application of wavelet analysis on fault diagnosis of interturn short circuit in rotor winding[J].Electric Machines & Control, 2007, 11(2):143-147.
[11] NAGEL L, GALEAZZI R, VOIGT A J, et al. Fault diagnosis of active magnetic bearings based on Gaussian GLRT detector[C] // Proceedings of the 3rd Control and Fault-Tolerant Systems. New York, USA: IEEE, 2016:540-547.
[12] DOHNAL F, SEKHAR A S. Current signature analysis for unbalance fault detection in a rotor supported by active magnetic bearings[J]. International Journal of Condition Monitoring, 2014, 4(1):2-8(7).
[13] TSAI N C, KING Y H, LEE R M. Fault diagnosis for magnetic bearing systems[J]. Mechanical Systems & Signal Processing, 2009, 23(4):1339-1351.
[14] LOESCH F. Detection and correction of actuator and sensor faults in active magnetic bearing system[C] //Proceedings of the 8th International Symposium on Magnetic Bearing. Zurich, Switzerland: vdf Hochschulverlag AG an der ETH Zurich, 2002:113-118.
[15] 常肖,徐龙祥,董继勇.磁悬浮轴承数字功率放大器[J].机械工程学报,2010,46(20):9-14. CHANG Xiao, XU Longxiang, DONG Jiyong. Digital power amplifier of active magnetic bearing[J]. Journal of Mechanical Engineering, 2010, 46(20): 9-14.
[16] WANG J, XU L. System model of three-level switching power amplifier for magnetic bearing[C] // International Conference on Measuring Technology and Mechatronics Automation. New York, USA: IEEE Computer Society, 2009:708-711.
[17] 臧晓敏,王晓琳,仇志坚,等. 磁轴承开关功放中电流三态调制技术的研究[J]. 中国电机工程学报,2004,24(9): 167-172. ZANG Xiaomin, WANG Xiaolin, QIU Zhijian, et al. Research on current modetri-state modulation technology in switching power amplifier for magnetic bearing[J]. Proceedings of the CSEE, 2004, 24(9): 167-172.
[18] 程鑫, 曾红勇, 吴华春,等. 磁悬浮开关功放数学模型与控制实现[J]. 华中科技大学学报(自然科学版), 2015(增刊1):493-496. CHENG Xin, ZENG Hongyong, WU Huachun, et al. Mathematical model and control implementation of switching power amplifier in magnetical-levitated system[J]. Journal of Huazhong University of Science & Technology(Natural Science Edition), 2015(Suppl. 1):493-496.
[19] CHENG X, WANG B, CHEN Q, et al. A unified design and the current ripple characteristic analysis of digital switching power amplifier in active magnetic-levitated bearings[J]. International Journal of Applied Electromagnetics & Mechanics, 2017, 55(3):391-407.
[20] 王军,徐龙祥. 磁悬浮轴承开关功率放大器等效数学模型[J]. 电工技术学报,2010,25(4):54-58. WANG Jun, XU Longxiang. Equivalent mathematical model of switched power amplifier for magnetic bearings[J]. Journal of electrical technology, 2010, 25(4):54-58.
[21] 张亮, 房建成. 基于MATLAB的电磁轴承开关功放建模与仿真研究[J]. 系统仿真学报, 2007, 19(11):2395-2398. ZHANG Liang, FANG Jiancheng. Research on modeling and Simulation of switching power amplifier for active magnetic bearing applications based on MATLAB[J]. Journal of System Simulation, 2007, 19(11):2395-2398.
[1] Jiachen WANG,Xianghong TANG,Jianguang LU. Research onfeature selection technology in bearing fault diagnosis [J]. Journal of Shandong University(Engineering Science), 2019, 49(2): 80-87, 95.
[2] CHENG Xin, LIU Han, WANG Bo, LIANG Dian, CHEN Qiang. A fault-tolerant control architecture for active magnetic bearing based on dual core processor [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2018, 48(2): 72-80.
[3] LIU Zhuo, WANG Tianzhen, TANG Tianhao, FENG Yefan, YAO Junqi, GAO Diju. A fault diagnosis and fault-tolerant control strategy for multilevel inverter [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 229-237.
[4] SUN Yuancheng, YAO Lina. Fault diagnosis and fault tolerant control for non-Gaussian uncertain singular stochastic distribution control systems [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 238-245.
[5] XIE Xiaolong, JIANG Bin, LIU Jianwei, JIANG Yinhang. Fault diagnosis and fault tolerant control based on sliding mode observer for speed sensor in asynchronous motor [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 210-214.
[6] WU Jianping, JIANG Bin, LIU Jianwei. Fault diagnosis of asynchronous motor based on wavelet packet entropy and wavelet neural network [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 223-228.
[7] WANG Mengyuan, ZHANG Xiong, MA Liang, PENG Kaixiang. Fault diagnosis for industrial processes based on causal topological graph [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 187-194.
[8] MAO Haijie, LI Wei, WANG Kehong, FENG Xiaolin. Sensor fault tolerant switch strategy for multi-motor synchronous system based on ADRC [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 64-70.
[9] SONG Yang, ZHONG Maiying. Fault isolability analysis based on improved distance similarity [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 103-109.
[10] CUI Yang, ZHANG Ke, JIANG Bin. Fault estimation design for linear multi-agent systems with switching topologies [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 263-270.
[11] LI Minghu, LI Gang, ZHONG Maiying. Application of dynamic kernel principal component analysis in unmanned aerial vehicle fault diagnosis [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 215-222.
[12] WANG Xiuqing, ZENG Hui, XIE Fei, LYU Feng. Fault diagnosis for manipulators based on Spiking neural networks [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 15-21.
[13] QIU Lu, YE Yinzhong, JIANG Chundi. Fault diagnostic method for micro-grid based on wavelet singularity entropy and SOM neural network [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 118-122.
[14] LI Wei, WANG Kehong, CAO Huichao. A fault filtering method based on an improved extended state filter for nonlinear system [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 7-14.
[15] LI Jingli, WANG Qian, ZHANG Jun, LI Leilei. Online modal parameter identification and fault diagnosis of wind turbines based on order analysis [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(4): 96-102.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] SUN Guohua, WU Yaohua, LI Wei. The effect of excise tax control strategy on the supply chain system performance[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 63 -68 .
[2] WANG Pei,ZHANG Yanning,SHEN Jiazhen,LIU Juncheng, . Application of information measure and support vector machine in image edge detection[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(3): 95 -99 .
[3] LI Hui-ping, ZHAO Guo-qun, ZHANG Lei, HE Lian-fang. The development status of hot stamping and quenching of ultra high-strength steel[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2010, 40(3): 69 -74 .
[4] SUN Weiwei， WANG Yuzhen. Finite gain stabilization of singlemachine infinite bus system subject to saturation[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 69 -76 .
[5] SUN Yu-li,LI De-fa,ZUO Dun-wen,QI mei . [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(6): 19 -23 .
[6] XUE Cheng-qian,DONG Jian-wen,MENG Xian-feng,CHANG Hong,CAO Ning,CHEN Hua-ying,LI Mu-sen . The effect of C／C+HA bonerepairing material to the physiological and biochemical response of the crossed Boer Goat[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(3): 73 -76 .
[7] ZHANG Yong-hua,WANG An-ling,LIU Fu-ping . The reflected phase angle of low frequent inhomogeneous[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 22 -25 .
[8] . [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 27 -32 .
[9] WANG Jing,LI Yu-jiang,ZHANG Xiao-jin,BI Yan-jun,CHEN Wei-suo . [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(6): 100 -103 .
[10] CAI Xiaojun １, ZHAGN Qing １, CHAI Qiaolin 1, KONG Suli 2. AnDivided multipath dynamic source routing based on energybalanced[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(2): 141 -145 .
Copyright 2018 © Editorial office of Journal of Shandong University (Engineering Science)
Supported by Beijing Magtech Co.Ltd