您的位置：山东大学 -> 科技期刊社 -> 《山东大学学报（工学版）》

山东大学学报(工学版) ›› 2015, Vol. 45 ›› Issue (2): 89-94.doi: 10.6040/j.issn.1672-3961.0.2014.226

• 化学与环境 • 上一篇    

聚合物/表面活性剂驱模拟采出水的乳化稳定性

苗领, 李玉江, 李枫   

  1. 山东大学环境科学与工程学院, 山东 济南 250100
  • 收稿日期:2014-08-12 修回日期:2015-03-17 出版日期:2015-04-20 发布日期:2014-08-12
  • 通讯作者: 李玉江(1963-),男,山东章丘人,教授,博导,博士,主要研究方向为水污染控制理论,废水治理工程与资源化和环境材料.E-mail:yujiang@sdu.edu.cn E-mail:yujiang@sdu.edu.cn
  • 作者简介:苗领(1987-),男,河南商丘人,硕士研究生,主要研究方向为水污染防治理论与技术.E-mail:sdmiaoling@126.com*
  • 基金资助:
    国家自然科学基金资助项目(51178253);山东省自然科学基金资助项目(ZR2011EEM002)

Emulsion stability of simulated polymer/surfactant flooding produced water

MIAO Ling, LI Yujiang, LI Feng   

  1. School of Environmental Science and Engineering, Shandong University, Jinan 250100, Shandong, China
  • Received:2014-08-12 Revised:2015-03-17 Online:2015-04-20 Published:2014-08-12

PDF (PC)

559

摘要： 以成分相对简单的轻质油(V(石油醚):V(苯)=9:1)作为模拟油取代成分复杂的原油配制模拟采出水,详细探究了驱油剂影响聚合物/表面活性剂二元复合驱采出水乳化稳定性的机理。采用超低界面张力仪、Zeta电位分析仪和界面流变仪对油水界面张力、油滴表面Zeta电位和油水界面流变进行测定,研究了部分水解聚丙烯酰胺(HPAM,聚合物)、石油磺酸盐(WPS,表面活性剂)和矿化度对模拟采出水油水分离性能的影响。研究结果表明:WPS能够降低油水界面张力,使模拟采出水更加稳定。HPAM能够增加模拟采出水体相黏度,但对其最终乳化稳定性影响较小。矿化度增加显著增强了模拟采出水乳化稳定性,从而为进一步加深对采出水乳化稳定性的研究提供借鉴。

关键词: 矿化度, 轻质油, 聚合物/表面活性剂驱, 乳化稳定性, 模拟采出水

Abstract: The mechanism of oil-displacing agent for the emulsion stability of polymer/surfactant produced water was studied in detail by preparing the simulated polymer/surfactant flooding produced water with light oil (V(petroleum ether):V(benzene)=9:1), which had a comparatively simple component instead of crude oil with complex component. The interfacial tension, Zeta potential of oil droplets and the rheology of oil-water interface were investigated by spinning drop inferface tensiometer, Zeta potential analyzer and surface rheology analyzer.The effects of WPS (petroleum sulfonate), HPAM (partially hydrolyzed polyacrylamide)and salinity on oil-water separation were studied. The results showed that WPS could reduce the interfacial tension and enhance the stability of produced water.With the concentration of HPAM increasing, the bulk phase viscosity increased, which had little effects on final emulsion stability. The increasing salinity could greatly enhance the stability of produced water, which could provide reference for the study of emulsion stability of produced water.

Key words: simulated produced water, light oil, emulsion stability, polymer/surfactant flooding, salinity

中图分类号: 

  • X703
[1] 王燕, 李玉江, 孙德军, 等. 锂皂石颗粒对聚合物驱采出水乳化稳定性的影响[J]. 山东大学学报:工学版, 2012, 42(3):115-119. WANG Yan, LI Yujiang, SUN Dejun, et al. Effects of hectorite particles on emulsification stability of polymer flooding produced water[J]. Journal of Shandong University:Engineering Science, 2012, 42(3):115-119.
[2] WANG B, WU T, LI Y J, et al. The effects of oil displacement agents on the stability of water produced from ASP(alkaline/surfactant/polymer) flooding[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2011, 379(1-3):121-126.
[3] 马宝东, 高宝玉, 卢磊, 等. 聚合物/表面活性剂二元体系油水乳化过程动态表征方法研究[J]. 山东大学学报:工学版, 2010, 40(4):117-120. MA Baodong, GAO Baoyu, LU Lei, et al. A characterization method of oil-water emulsion dynamic characteristics in surfactant/polymer flooding[J]. Journal of Shandong University:Engineering Science, 2010, 40(4):117-120.
[4] ZHANG R, LIANG C, WU D, et al. Characterization and demulsification of produced liquid from weak base ASP flooding[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2006, 290(1-3):164-171.
[5] DENG S, YU G, JIANG Z, et al. Destabilization of oil droplets in produced water from ASP flooding[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2005, 252(2-3):113-119.
[6] KANG W L, XU B, WANG Y J, et al. Stability mechanism of W/O crude oil emulsion stabilized by polymer and surfactant[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2011, 384(1-3):555-560.
[7] 靖波, 张健, 吕鑫, 等. 界面扩张流变法研究部分水解聚丙烯酰胺与表面活性剂相互作用[J]. 油田化学, 2011, 28(4):431-434. JING Bo, ZHANG Jian, LV Xin, et al. Studies on the interactions between partially hydrolyzed polyacrylamide and surfactants by interfacial dilational rheology[J]. Oilfield Chemistry, 2011, 28(4):431-434.
[8] FAN Y, SIMON S, SJBLOM J. Interfacial shear rheology of asphaltenes at oil-water interface and its relation to emulsion stability: influence of concentration, solvent aromaticity and nonionic surfactant[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2010, 366(1-3):120-128.
[9] POTEAU S, ARGILLIER J. Influence of pH on stability and dynamic properties of asphaltenes and other amphiphilic molecules at the oil-water interface[J]. Energy and Fuels, 2005, 19(4):1337-1341.
[10] LIU J, ZHANG L, XU Z, et al. Colloidal interactions between asphaltene surfaces in aqueous solutions[J]. Langmuir, 2006, 22(4):1485-1492.
[11] ORTIZ D P, BAYDAK E N, YARRANTON H W. Effect of surfactants on interfacial films and stability of water-in-oil emulsions stabilized by asphaltenes[J]. Journal of Colloid and Interface Science, 2010, 351(2):542-555.
[12] ÁLVAREZ L, DÍAZ M E, MONTES F J, et al. Langmuir technique and Brewster angle microscope studies of the interfacial behavior of bitumen, asphaltenes and maltenes at the air-water interface. I. Effect of different spreading solution volumes[J]. Fuel, 2010, 89(3):691-702.
[13] ZHAO Z, LI Z, QIAO W, et al. Dynamic interfacial behavior between crude oil and octylmethylnaphthalene sulfonate surfactant flooding systems[J]. Journal of Colloid and Interface Science, 2005, 259(1-3):71-80.
[14] ZHAO Z, BI C, QIAO W, et al. Dynamic interfacial tension behavior of the novel surfactant solutions and Daqing crude oil[J]. Journal of Colloid and Interface Science, 2007, 294(1-3):191-202.
[15] ASKE N, ORR R, SJBLOM J. Dilatational elasticity moduli of water-crude oil interfaces using the oscillating pendant drop[J]. Journal of Dispersion Science and Technology, 2002, 23(6):809-825.
[16] SZTUKOWSKI D M, YARRANTON H W. Rheology of asphaltene-toluene/water interfaces[J]. Langmuir, 2005, 21(25):11651-11658.
[17] 何文文, 李玉江, 孙蕾蕾, 等. 钠蒙脱土颗粒对模拟采出水乳化稳定性的影响[J]. 济南大学学报:自然科学版, 2014, 28(6):411-415. HE Wenwen, LI Yujiang, SUN Leilei, et al. Effects of na-montmorillonite particles on emulsification stability of simulated produced water[J]. Journal of University of Jinan:Science and Technology, 2014, 28(6):411-415.
[18] KHAN M Y, SAMANTA A, OJHA K, et al. Interaction between aqueous solutions of polymer and surfactant and its effect on physicochemical properties[J]. Asia-Pacific Journal of Chemical Engineering, 2008, 3(5):579-585.
[19] NAMBAM J S, PHILIP J. Competitive adsorption of polymer and surfactant at a liquid droplet interface and its effect on flocculation of emulsion[J]. Journal of Colloid and Interface Science, 2012, 366(1):88-95.
[20] MA B D, GAO B Y, YUE Q Y. Study on emulsification stability of wastewater produced by polymer flooding[J]. Journal of Petroleum Science and Engineering, 2013, 110(10):27-31.
[21] SANTOS F K G, NETO E L B, MOURA M C P A, et al. Molecular behavior of ionic and nonionic surfactants in saline medium[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2009, 333(1-3):156-162.
[22] VAKARELSKI I U, DUSHKIN C D. Effect of the counterions on the surface properties of surfactant solutions:kinetics of the surface tension and surface potential[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2000, 163(2):177-190.
[23] 赵涛涛, 宫厚健, 徐桂英, 等. 阴离子表面活性剂在水溶液中的耐盐机理[J]. 油田化学, 2010, 27(1):112-118. ZHAO Taotao, GONG Houjian, XU Guiying, et al. Investigation of salts tolerance of anionic surfactants in aqueous solutions[J]. Oilfield Chemistry, 2010, 27(1):112-118.
[24] 杜娟, 曾宪诚. 金属盐作用下的表面活性剂临界胶束浓度的变化研究[J]. 四川大学学报:自然科学版, 2002,39(4):721-724. DU Juan, ZENG Xiancheng. An investigation on the variation of critical micelle concentrations of CTAB and SDS surfactants influenced by salts[J]. Journal of Si Chuan University:Science and Technology, 2002, 39(4):721-724.
[25] JUSUFI A, HYNNINEN A, HAATAJA M, et al. Electrostatic screening and charge correlation effects in micellization of ionic surfactants[J]. The Journal of Physical Chemistry B, 2009, 113(18):6314-6320.
[26] AVEYARD R, BINKS B P, CLARK S, et al. Interfacial tension minima in oil-water-surfactant systems. Behaviour of alkane-aqueous NaCl systems containing aerosol OT[J]. Journal of the Chemical Society, 1986, 82(1):125-142.
[1] 孙树青,孙丰凯,梁爽,徐晓丽. 一种无机复合絮凝剂的制备及其对染料废水的处理[J]. 山东大学学报(工学版), 2018, 48(2): 128-133.
[2] 李发站,张帅,张建,梁爽. C-CBR一体化生物反应器处理农村生活污水研究[J]. 山东大学学报(工学版), 2018, 48(1): 124-130.
[3] 袁莎莎,于海波,高明明,王新华. 有机碳源缺乏对成熟好氧颗粒污泥性能的影响[J]. 山东大学学报(工学版), 2017, 47(4): 124-130.
[4] 余美琼, 杨金杯, 陈秀宇, 邓殳. 松树锯末对Pb(II)与Ni(II)的吸附研究[J]. 山东大学学报(工学版), 2015, 45(2): 75-81.
[5] 饶敏1,李燕红1,陈伟华1,宋建波2,陈广大1,刘晓作1. 二硝基重氮酚工业废水处理研究[J]. 山东大学学报(工学版), 2012, 42(6): 100-106.
[6] 原爱娟,岳钦艳,李倩,高宝玉,李静 . 颗粒膨润土的制备技术及对染料脱色性能的研究[J]. 山东大学学报(工学版), 2008, 38(5): 88-93 .
[7] 李善评,赵玉晓,乔鹏,冯正志 . 好氧颗粒污泥的培养及基质降解和污泥生长动力学分析[J]. 山东大学学报(工学版), 2008, 38(3): 95-98 .
[8] 赵玉晓,李善评,乔鹏,张启磊 . 曝气生物滤池的除磷效果及滤料生物相特征[J]. 山东大学学报(工学版), 2008, 38(1): 88-91 .
[9] 李善评,曹翰林,胡振,张启磊,赵玉晓,范思思 . 钛基PbO2的电极性能及用于酸性嫩黄2G废水处理的研究[J]. 山东大学学报(工学版), 2007, 37(6): 122-126 .
[10] 李善评,胡振,孙一鸣,甄博如,张启磊,曹翰林 . 新型钛基PbO2电极的制备及电催化性能研究[J]. 山东大学学报(工学版), 2007, 37(3): 109-113 .
[11] 郑楠, 李聪, 谢慧君, 张建. 碳源类型对反硝化除磷过程中N2O产生的影响机制[J]. 山东大学学报(工学版), 2014, 44(5): 72-77.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 2018 《山东大学学报(工学版)》编辑部　
地址: 济南市山大南路27号（250100）　 电话: 0531-88366735　 E-mail: xbgxb@sdu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发