您的位置：山东大学 -> 科技期刊社 -> 《山东大学学报（工学版）》

山东大学学报(工学版) ›› 2016, Vol. 46 ›› Issue (1): 56-61.doi: 10.6040/j.issn.1672-3961.0.2014.313

• • 上一篇    下一篇

掺合镀铜织物纤维电磁屏蔽砂浆性能研究

张宏博1,2,解全一1,2,岳红亚1,2*,孟庆宇1,2   

  1. 1. 山东大学土建与水利学院, 山东 济南 250061;
    2. 山东省路基安全工程技术研究中心, 山东 济南 250061
  • 收稿日期:2014-11-05 出版日期:2016-02-20 发布日期:2014-11-05
  • 作者简介:张宏博(1976- ),男,山东济宁人,副教授,博士,主要研究方向为地基处理与加固,建筑材料. E-mail:64437063@qq.com
  • 基金资助:
    国家自然科学基金资助项目(51208284)

Study on performance of electromagnetic shielding mortar mixed with copper coated fabric fiber

ZHANG Hongbo1,2, XIE Quanyi1,2, YUE Hongya1,2*, MENG Qingyu1,2   

  1. 1. School of Civil Engineering, Shandong university, Jinan 250061, Shandong, China;
    2. Shandong Engineering &
    Technology Research Center for Subgrade Safety, Jinan 250061, Shandong, China
  • Received:2014-11-05 Online:2016-02-20 Published:2014-11-05

PDF (PC)

1139

摘要： 为了研究纤维掺量、长度等因素对掺合镀铜织物纤维电磁屏蔽砂浆力学性能、导电性能、电磁屏蔽效能(shielding effectiveness, SE)的影响规律,设计了强度试验、电阻率试验和屏蔽效能试验研究了各因素对金属纤维砂浆性能的影响规律。研究结果表明:金属纤维能够增强砂浆的力学性能和导电性能,纤维砂浆抗折强度比普通砂浆增加14.2%~17.8%,抗压强度增加7.3%~23.1%,电阻率仅为普通砂浆的3.5%。掺加金属纤维后能够提高砂浆中高频电磁屏蔽效能,厚度为2 cm的金属纤维砂浆的体积分数为1%时SE值最高; SE值随着纤维长度的增加逐渐增大,长度为20 mm的金属纤维砂浆在0~700 MHz和2 000~3 000 MHz波频范围SE值较普通砂浆增加约10 dB;砂浆厚度对屏蔽效能影响明显,厚度为3 cm的纤维砂浆SE值几乎为厚度为2 cm的纤维砂浆的2倍,两种厚度砂浆的SE值均超过20 dB,最大值为50 dB。结论可为电磁屏蔽砂浆在民用建筑中的推广和应用提供借鉴。

关键词: 金属纤维, 导电性能, 力学性能, 屏蔽效能, 电磁屏蔽砂浆

Abstract: In order to study the influence of fiber dosage, length and other factors on the electromagnetic shielding mortar mixed with copper coated fabric fibers mechanical properties, conductivity and SE(shielding effectiveness), strength test, resistivity test and SE test were put forth. The influence law of the variable factors to the properties of mortar with metal fiber was found. Results showed that the metal fiber could enhance the mechanical properties and electrical conductivity of mortar. The flexural strength of fiber mortar increased about 14.2% to 17.8% than ordinary mortar the compressive strength increased about 7.3%~23.1% and the electrical resistance was only 3.5% of the ordinary mortar. The high frequency electromagnetic shielding effectiveness of the mortar could be improved when adding metal fiber, shielding effect was best when the volume fraction of 2 cm thickness of mortar with metal fiber was 1%. SE was gradually increasing with the increase of fiber length, and SE of 20 mm length mortar metal fiber increased about 10 dB in 0~700 MHz and 2 000~3 000 MHz wave frequency range than ordinary mortar. Mortar thickness had an significant influence on SE, the shielding effect of 3 cm thickness mortar with metal fiber was almost 2 times of the 2 cm thickness mortar with metal fiber mortar, both of which the SE were more than 20 dB, and the maximum was 50 dB. Conclusion of this study could provide reference for electromagnetic shielding mortars popularization and application in civil architecture.

Key words: metal fiber, mechanical properties, shielding effectiveness, electromagnetic shielding mortar, conductivity

中图分类号: 

  • TQ172
[1] 王普照,谭宏斌,冯小明,等.掺合材石墨不锈钢纤维对水泥基材料电磁屏蔽效能的影响研究[J].铸造技术, 2007,28(8):1105-1108.
[2] 司琼, 董发勤. 电磁屏蔽混凝土[J]. 材料导报, 2005,19(2):57-62. SI Qiong, DONG Faqin. Electromagnetic shielding concrete[J]. Materials Review, 2005,19(2):57-62.
[3] 伍崇明.核工程抗强辐射屏蔽混凝土试验研究[D].长沙:中南大学,2008. WU Chongming. The study on strong radiation shielding concrete test of nuclear engineering[D].Changsha: Central South University, 2008.
[4] 刘永肖.电磁屏蔽砂浆的研究[D].北京:北京工业大学, 2006. LIU Yongxiao. Research of electromagnetic interference shielding mortar[D].Beijing: Beijing University of Technology, 2006.
[5] 杨玉山,董发勤,邓强.掺石墨/碳纤维电磁屏蔽砂浆的研究[J].功能材料,2011,10(42):1844-1846. YANG Yushan, DONG Faqin, DENG Qiang. On electromagnetic shielding cement paste with graphite and carbon fiber[J]. Journal of Functional Materials, 2011,10(42):1844-1846.
[6] 孟超, 高燕, 于淼,等. 城市电磁辐射污染的产生与危害[J].安全,2005,26(5):29-33.
[7] 董波,高培伟,闫亚楠,等.具有电磁屏蔽功能的新型建筑材料研究[J].广东建材,2006(11):15-16.
[8] 沈刚,董发勤.电磁屏蔽混凝土及其发展趋势[J].混凝土,2004(10):5-7. SHEN Gang, DONG Faqin. Electromagnetic shielding concrete and developing trend[J]. Concrete, 2004(10):5-7.
[9] 伍崇明,丁德鑫,张辉赤.屏蔽混凝土配合比设计方法研究[J].核动力工程,2007,28(5):124-127. WU Chongming, DING Dexin, ZHANG Huichi. Methods for the design of shielding concrete mix ratio[J].Nuclear Power Engineering, 2007, 28(5):124-127.
[10] 伍崇明,丁德鑫,张辉赤,等.屏蔽混凝土性能试验[J].核动力工程,2009,30(3):141-144. WU Chongming, DING Dexin, ZHANG Huichi, et al. Performance test on shielding concrete[J]. Nuclear Power Engineering, 2009, 30(3):141-144.
[11] 伍崇明,丁德鑫,张辉赤,等. 屏蔽混凝土用原材料性能试验研究[J].混凝土,2007(12):60-64. WU Chongming, DING Dexin, ZHANG Huichi, et al. Study on performance test of raw material of shielding concrete[J].Concrete, 2007(12):60-64.
[12] 吕楠,梅全亭,康青,等.电磁屏蔽混凝土性能的数值模拟[J].后勤工学院学报,2009,25(1):16-18. LYU Nan, MEI Quanting, KANG Qing, et al. Study on numerical simulation of electrom agnetic shielding concrete[J]. Journal of Logistical Engineering University, 2009, 25(1):16-18.
[13] 吕楠,黄斌科,唐国峰,等. 建筑物内部电场强度分布特性数值模拟研究[J].后勤工学院学报,2013(6):6-10. LYU Nan, HUAN Binke, TANG Guofeng, et al. Numerical simulation of indoor electric-field strength distributing characteristics of buildings[J]. Journal of Logistical Engineering University, 2013(6):6-10.
[14] 吕楠,康青,张彭成,等. 短切碳纤维与铁氧体在低频电磁屏蔽混凝土中的实验研究[C] //第六届中国功能材料及其应用学术会议论文集.武汉:功能材料,2007.
[15] 吕楠,康青,郭华雨,等. 短切碳纤维混凝土电磁屏蔽规律的实验研究[J].后勤工学院学报,2006(2):15-18. LYU Nan, KANG Qing, GUO Huayu, et al. Analysis on absorbing wave rule of short carbon fibers concrrete with experiment[J]. Journal of Logistical Engineering University, 2006(2):15-18.
[16] BACHE Hans Hiroshi, ERIKSEN Knud Lund. Magnetic concrete with metal or alloy powder additions for electromagnetic apparatus[J]. Int Appl, 1992, 29(5):66.
[17] FU X, CHUNG D D L. Submicron carbon filament cement-matrixcomposites for electromagnetic interference shielding[J]. Cement and Concrete Research, 1997, 26(10):1467-1472.
[18] FU X, CHUNG D D L.Submicron-diameter-carbon-filament cement-matrix composites[J]. Carbon, 1998, 36(4):459-462.
[19] FU X, CHUNG D D L. Carbon fiber reinforced mortar as an electrical contact material for cathodic protection[J]. Cement and Concrete Research, 1995, 25(4):689-694.
[20] CHUNG D D L.Damage in cement-based materials, studied by electrical resistance measurement[J]. Materials Science and Engineering, 2003, 42(1):1-40.
[21] 中国建筑材料工业局.GB/T17671—1999水泥胶砂强度检测方法 [S].北京:中国标准出版社,1999.
[22] 钱觉时,徐珊珊,李美利,等.混凝土电阻率测量方法与应用[J].山东科技大学学报(自然科学版),2010,29(1):37-42. QIAN Jueshi, XU Shanshan, LI Meili, et al. The measurement and application of resistivity for concrete[J]. Journal of Shandong University of Science and Technology(Natural Science), 2010, 29(1):37-42.
[23] 刘志勇,詹镇峰.混凝土电阻率及其在钢筋混凝土耐久性评价中的应用研究[J].混凝土,2006(10):13-16. LIU Zhiyong, ZHAN Zhenfeng. Research on electrical resistivity of concrete and its application in durability appreciation of reinforced concrete[J]. Concrete, 2006(10):13-16.
[24] 徐青,汪卫东,周双喜,等. 铁氧体、石墨及钢纤维水泥复合砂浆电磁屏蔽性能的实验研究[J].硅酸盐通报, 2013, 32(1):89-93. XU Qing, WANG Weidong, ZHOU Shuangxi, et al. Study on electromagnetic shielding properties of ferrite,graphite and steel fiber cement composite mortars[J]. Bulletin of the Chinese Ceramic Society, 2013, 32(1):89-93.
[25] 赵灵智, 胡社军,何琴玉,等.电磁屏蔽材料的屏蔽原理与研究现状[J].包装工程,2006,27(2):1-5. ZHAO Lingzhi, HU Shejun, HE Qinyu, et al. Shielding principle and research progress of electromagnetic shielding materials[J].Packaging Engineering, 2006, 27(2):1-5.
[1] 曹芙波,肖胜先,王晨霞,郜德龙,李敦,苏天,秦士杰,王宇飞. 基于熵权TOPSIS的再生砖混水稳材料多指标综合性能评价[J]. 山东大学学报 (工学版), 2025, 55(6): 151-162.
[2] 薛刚,刘秋雨,董伟,李京军. 冲击荷载下钢渣细骨料混凝土力学特性及本构关系[J]. 山东大学学报 (工学版), 2025, 55(4): 108-117.
[3] 薛刚,邬松,董伟. 碳化钢渣细骨料混凝土本构关系[J]. 山东大学学报 (工学版), 2025, 55(2): 97-105.
[4] 罗靓,晏宇翔,吕辉,张成明. 异形钢管混凝土轴压短柱力学性能[J]. 山东大学学报 (工学版), 2024, 54(3): 103-114.
[5] 潘旭东,李鸿钊,郭焱旭,刘人太,何万里. 海洋环境下注浆加固体的力学性能演化[J]. 山东大学学报 (工学版), 2023, 53(5): 112-120.
[6] 王晓明,朱传超,许航,贺耀北,韩昭,李兆辉,黄春杨. 无内腹板式钢索塔锚固区的力学性能分析[J]. 山东大学学报 (工学版), 2023, 53(3): 50-59.
[7] 赵之仲,柳泓哲,唐亮,杨振宇,王日升. 强化方式与材料对再生粗集料的性能规律分析[J]. 山东大学学报 (工学版), 2023, 53(1): 11-17.
[8] 周勇,李召峰,左志武,王川,林春金,张新,姚望. 滨海岩溶注浆充填体性能研究[J]. 山东大学学报 (工学版), 2022, 52(1): 103-110.
[9] 杨炎,王威强,潘路,宋明大. 服役后16Mn管材应变时效的自动球压痕测试[J]. 山东大学学报(工学版), 2017, 47(4): 64-69.
[10] 李明,朱召泉,刘琳. 混凝土压缩试验的改善及动态损伤[J]. 山东大学学报(工学版), 2017, 47(1): 68-75.
[11] 苏成功,刘燕,王威强, 王玉花. 压痕对不锈钢材料表面残余应力的影响[J]. 山东大学学报(工学版), 2017, 47(1): 90-96.
[12] 张万志,刘华,张峰,高磊,姚晨,刘冠之. 斜拉桥塔梁同步施工过程的力学特性[J]. 山东大学学报(工学版), 2016, 46(6): 120-126.
[13] 彭元诚,董旭,梁娜,邓振全. 北盘江新型空腹式连续刚构桥角隅节点模型试验研究[J]. 山东大学学报(工学版), 2016, 46(6): 113-119.
[14] 胡顺鹏1,赵洪石2,王冠聪2,曹成波1*,刘宏2*,李文波1,杨晓宇1. 一种胶原支架材料的结构与性能表征[J]. 山东大学学报(工学版), 2010, 40(4): 67-71.
[15] 孙丽莉, 贾玉玺, 孙胜, 马凤德.

界面强度对纤维复合材料破坏及力学性能的影响

[J]. 山东大学学报(工学版), 2009, 39(2): 101-103.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] 王素玉,艾兴,赵军,李作丽,刘增文 . 高速立铣3Cr2Mo模具钢切削力建模及预测[J]. 山东大学学报(工学版), 2006, 36(1): 1 -5 .
[2] 李 侃 . 嵌入式相贯线焊接控制系统开发与实现[J]. 山东大学学报(工学版), 2008, 38(4): 37 -41 .
[3] 孔祥臻,刘延俊,王勇,赵秀华 . 气动比例阀的死区补偿与仿真[J]. 山东大学学报(工学版), 2006, 36(1): 99 -102 .
[4] 陈瑞,李红伟,田靖. 磁极数对径向磁轴承承载力的影响[J]. 山东大学学报(工学版), 2018, 48(2): 81 -85 .
[5] 李可,刘常春,李同磊 . 一种改进的最大互信息医学图像配准算法[J]. 山东大学学报(工学版), 2006, 36(2): 107 -110 .
[6] 季涛,高旭,孙同景,薛永端,徐丙垠 . 铁路10 kV自闭/贯通线路故障行波特征分析[J]. 山东大学学报(工学版), 2006, 36(2): 111 -116 .
[7] 浦剑1 ,张军平1 ，黄华2 . 超分辨率算法研究综述[J]. 山东大学学报(工学版), 2009, 39(1): 27 -32 .
[8] 王丽君,黄奇成,王兆旭 . 敏感性问题中的均方误差与模型比较[J]. 山东大学学报(工学版), 2006, 36(6): 51 -56 .
[9] 孙殿柱,朱昌志,李延瑞 . 散乱点云边界特征快速提取算法[J]. 山东大学学报(工学版), 2009, 39(1): 84 -86 .
[10] 赵然杭,陈守煜 . 水资源数量与质量联合评价理论模型研究[J]. 山东大学学报(工学版), 2006, 36(3): 46 -50 .
版权所有 © 2018 《山东大学学报(工学版)》编辑部　
地址: 济南市山大南路27号（250100）　 电话: 0531-88366735　 E-mail: xbgxb@sdu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发