烟气成分对湿式电除尘器电晕放电特性的影响

doi:10.6040/j.issn.1672-3961.0.2019.748

摘要/Abstract

摘要： 建立单通道线板式湿式电除尘器机理实验台,考察烟气中主要成分(O₂、H₂O和粉尘)对湿式静电除尘器放电特性的影响。随着烟气成分(O₂、H₂O和粉尘)浓度的增加,空间静电场中负电荷密度增加,电场分布均匀性提高,抑制电晕放电,电晕电流降低;随着电压升高,烟气成分对电晕放电的抑制作用减弱。其中,烟气中O₂的体积分数增加引起电晕电流下降的速率不为常数,O₂体积分数小于6%时,下降速率明显减小。烟气中液相水滴附着在电晕线表面引起表面电场畸化,起晕电压降低,击穿电压提高,湿式静电除尘器的工作电压窗口增大。电晕电流与烟气中粉尘浓度呈线性相关关系,粉尘粒径越小对电晕放电的抑制作用越明显。

关键词: 湿式静电除尘器, 烟气成分, 起晕电压, 击穿电压, 静电场均匀性

Abstract: To study the effects of gas components on the corona discharge characteristics of the wet electrostatic precipitator, a test bench was built. The effect of O₂, H₂O, and dust concentration on the discharge current were discussed in detail, results show than the O₂, H₂O and, dust in the flue gas had an inhibitory effect on the corona discharge and the negative ion concentration and electrostatic-field uniform were greatly improved with the increase of the O₂, H₂O, and dust concentration in the flue gas. The inhibitory effect of these components on the discharge current became weaker on a higher applied voltage. The descending rate of the discharge current was not a constant with the increase of O₂ concentration in the flue gas when the O₂ concentration was higher than 6%, the discharge current descended rapidly. The distribution of the electricfieldon the surface of the discharge electrode was twisted because of the aggregation of the liquid droplets. Wet electrostatic precipitator had a wide range of operating voltages and the onset voltage was lower and the breakdown voltage was higher under high water content in the flue gas. Dust concentration showed a linear correlation of the discharge current and the inhibitory effect increased when the dimensions of dust were smaller.

Key words: wet electrostatic precipitator, gas components, onset voltage, breakdown voltage, electrostatic-field uniformity

中图分类号:

TM89

王磊,张玉磊,李兆东,张金峰,王翔. 烟气成分对湿式电除尘器电晕放电特性的影响[J]. 山东大学学报 (工学版), 2020, 50(5): 83-89.

WANG Lei, ZHANG Yulei, LI Zhaodong, ZHANG Jinfeng, WANG Xiang. Effect of gas components on the discharge characteristics of the wet electrostatic precipitator[J]. Journal of Shandong University(Engineering Science), 2020, 50(5): 83-89.

参考文献

[1] 武占成,张希军.气体放电[M].北京:国防工业出版社,2012.
[2] 郑乐民.原子物理[M].2版.北京:北京大学出版社,2010.
[3] STAEHLE R C, TRISCORI R J, KUMAR K S. Wet electrostatic precipitators for high efficiency control of fine particulates and sulfuric acid mist[C] //Institute of Clean Air Companies Forum Arlington. Arlington, USA: IEEE, 2003.
[4] 张华东,周宇翔,龙辉.湿式电除尘器在燃煤电厂的应用条件分析[J].中国电力,2015,48(8):13-16. ZHANG Huaodong, ZHOU Yuxiang, LONG Hui. Study on application conditions of wet electrostatic precipitators in coal-fire power plants[J].Electric Power, 2015, 48(8):13-16.
[5] 颜金培,杨林军,鲍静静.湿法脱硫烟气中细颗粒物的变化特性[J].东南大学学报(自然科学版),2011,41(2):387-392. YAN Jinpei, YANG Linjun, BAO Jingjing. Impact property on fine particles from coal combustion in wet flue gas desulfurization process[J]. Journal of Southeast University(Natural Science Edition), 2011, 41(2):387-392.
[6] 鲍静静,杨林军,颜金培.湿法烟气脱硫系统对细颗粒脱除性能的实验研究[J].化工学报,2009,60(5):1260-1267. BAO Jingjing, YANG Linjun, YAN Jinpei. Performance of removal of fine particles by WFGD system[J].CIESC Journal, 2009, 60(5):1260-1267.
[7] 王珲,宋蔷,姚强,等.电厂湿法脱硫系统对烟气中细颗粒物脱除作用的实验研究[J].中国电机工程学报,2008,28(5):1-7. WANG Hui, SONG Qiang, YAO Qiang, et al. Experimental study on removal effect of wet flue gas desulfurization system on fine particles from a coal-fired power plant[J]. Proceedings of the CSEE, 2008, 28(5):1-7.
[8] 丁志江,杨志燕,肖立春,等.线板极配湿式电除尘器电晕放电及收尘性能试验研究[J].燕山大学学报,2015,39(2):177-181. DING Zhijiang, YANG Zhiyan, XIAO Lichun, et al. Experimental research on performance of corona discharge and dust remove of wire-plate wet electrostatic precipitator[J]. Journal of Yanshan University, 2015, 39(2):177-181.
[9] 刘丽娜,丁志江,肖立春.湿式电除尘器伏安特性的实验研究[J].环境工程,2012(增刊2):187-189. LIU Lina, DING Zhijiang, XIAO Lichun. Experimental study on V-I characteristics of wet electrostatic precipitator[J].Environmental Engineering, 2012(Suppl.2):187-189.
[10] 王晓华.静电场中水对颗粒物脱出增强机理与过程[D].北京:清华大学,2013. WANG Xiaohua. Enhancement mechanism and process of water on particle removal in electrostatic field[D].Beijing:Tsinghua University, 2013.
[11] CHANG Jingcai, DONG Yong, WANG Zhiqiang. Removal of sulfuric acid aerosol in a wet electrostatic precipitator with single terylene or polypropylene collection electrodes[J]. Journal of Aerosol Science, 2011, 42(8):544-554.
[12] 徐纯燕,常景彩,孟镇,等.单股流布水改性碳钢表面的润湿特性[J].化工学报,2014,66(2):669-677. XU Chunyan, CHANG Jingcai, MENG Zhen, et al. Wetting characteristics experiment of modified carbon steel surface with single strand flow[J]. CIESC Journal, 2014, 66(2):669-677.
[13] MARJAMAKI M, KESKINEN J, CHEN D R. Performance evaluation of the electrical low-pressure impactor(ELPI)[J]. Journal of Aerosol Science, 2000, 31(2):249-261.
[14] HERNANDEZS A, ALGUACIL F J, ALONSO M. Unipolar charging of nanometer aerosol particles in a corona ionizer[J].Journal of Aerosol Science, 2003, 34(6):733-745.
[15] MACDONALD J R, BARLOW A. Work function change on monolayer adsorption[J].The Journal of Chemical Physics, 1963, 39(2):412-422.
[16] SCHNUR S, GROB A. Properties of metal-water interfaces studied from first principles[J].New Journal of Physics, 2009, 11(12):1-25.
[17] MUSUMECI F, POLLACK G H. Influence of water on the work function of certain metals[J].Chemical Physics Letters, 2012, 536:65-67.
[18] 徐明铭.空气湿度对直流电晕放电影响的研究[D].济南:山东大学,2014. XU Mingming. Study on influences of air humidity on direct current corona discharge[D]. Jinan: Shandong University, 2014.
[19] 王清亮,张璐,李舟,等.空气湿度对导线电晕起始电压的影响[J].电力建设,2009(8):38-41. WANG Qingliang, ZHANG Lu, LI Zhou, et al. Influence of humidity on conductor corona onset voltage[J]. Electric Power Construction, 2009(8):38-41.
[20] 颜金培,杨林军,鲍静静,等.氨法脱硫过程烟气中细颗粒物的变化特性[J].中国电机工程学报,2009,29(5):21-26. YAN Jinpei, YANG Linjun, BAO Jingjing, et al. Impact property on fine particles from coal combustion in ammonia flue gas desulfurization process[J].Proceedings of the CSEE, 2009, 29(5):21-26.

多维度评价

Viewed

Full text

Abstract

Cited

Shared

Discussed