您的位置:山东大学 -> 科技期刊社 -> 《山东大学学报(工学版)》

山东大学学报(工学版) ›› 2014, Vol. 44 ›› Issue (4): 58-63.doi: 10.6040/j.issn.1672-3961.0.2013.360

• 能源与动力工程 • 上一篇    下一篇

四分仓回转式空气预热器热力计算方法

陈昌贤, 孙奉仲, 李飞, 吴艳艳   

  1. 山东大学能源与动力工程学院, 山东 济南 250061
  • 收稿日期:2013-11-29 修回日期:2014-03-05 发布日期:2013-11-29
  • 通讯作者: 孙奉仲(1962-),男,山东郓城人,教授,博士生导师,主要研究方向为电站热力设备节能与经济性控制.E-mail:sfzh@sdu.edu.cn E-mail:sfzh@sdu.edu.cn
  • 作者简介:陈昌贤(1988-),男,福建大田人,硕士研究生,主要研究方向为电站热力设备节能与经济性控制.E-mail:sdu_ccxian@163.com

Thermal calculation method for quad-sectional regenerative air preheater

CHEN Changxian, SUN Fengzhong, LI Fei, WU Yanyan   

  1. School of Energy and Power Engineering, Shandong University, Jinan 250061, Shandong, China
  • Received:2013-11-29 Revised:2014-03-05 Published:2013-11-29

摘要: 基于四分仓空气预热器的运行方式和传热特点的分析,建立了先合仓再分仓的热力计算模型。模型包含合仓和分仓两步计算,通过合仓计算获得平均出口烟温和有加权的平均出口风温;利用合仓计算结果进行分仓计算,获得右二次风仓、一次风仓和左二次风仓的平均出口风温。结果表明,计算值与设计值的最大相对偏差为2.27%,最小相对偏差为0.21%。以某300 MW循环流化床锅炉机组的四分仓空气预热器为实例,在4个常用工况下,计算值与实际运行数据的最大相对偏差为4%,平均相对偏差为1.8%,验证了此计算方法的准确性和可靠性。

关键词: 热力计算, 回转式空气预热器, 四分仓, 传热模型, 相对偏差

Abstract: A new thermal calculation model for quad-sectional regenerative air preheater was investigated based on the analysis of operating mode and heat transfer characteristics of quad-sectional air preheaters. The model included two calculating steps: the average outlet flue gas temperature and the weighted average outlet air temperature were obtained through the first step calculation; and based on the first step calculation results, the average outlet air temperatures were obtained in right-secondary airside, primary air side and left-secondary airside respectively by the second step calculation. The results showed that the maximum and minimum relative deviations between calculated values and design values were 2.27% and 0.21% respectively. For a 300 MW circulating fluidized bed boiler unit with quad-sectional air preheater, the maximum and average relative deviations between calculated values and actual operation data were 4% and 1.8% respectively, the accuracy and reliability of this thermal calculation model were verified.

Key words: quad-sectional, regenerative air preheater, heat transfer model, relative deviation, thermal calculation

中图分类号: 

  • TK222
[1] 马悦,孙奉仲,史月涛,等. 电站锅炉回转式空气预热器漏风率过高的分析与对策[J]. 电站系统工程, 2007, 23(02):20-22. MA Yue, SUN Fengzhong, SHI Yuetao, et al. Analysis and measures for high air leakage of rotary air preheater of utility boiler [J]. Power System Engineering, 2007, 23(02):20-22.
[2] 金小峰. 基于有限差分的四分仓回转式空气预热器传热性能数值计算[D]. 上海:上海交通大学,2007. JIN Xiaofeng. Quad-sector air-preheater performance evaluation based on numerical finite difference method[D]. Shanghai: Shanghai Jiao Tong University, 2007.
[3] 北京锅炉厂设计科. 锅炉机组热力计算标准方法[M]. 北京: 机械工业出版社, 1976.
[4] 周强泰,周克毅,冷伟,等. 锅炉原理[M]. 北京: 中国电力出版社, 2009.
[5] 郑凯,周克毅,黄军林. 一种改进的三分仓空气预热器热力计算方法[J]. 动力工程学报,2012,32(01):31-35. ZHENG Kai, ZHOU Keyi, HUANG Junlin. An improved thermal calculation method for tri-sectional rotary air preheaters[J]. Journal of Chinese Society of Power Engineering, 2012, 32(01):31-35.
[6] 阎维平,李皓宇,黄景立,等. 电站锅炉三分仓回转式空气预热器热力计算方法研究[J]. 热力发电, 2009, 38(03): 44-47. YAN Weiping, LI Haoyu, HUANG Jingli, et al. Study on thermodynamic calculation of tri-section regenerative air preheater for utility boilers[J]. Thermal Power Generation Publishing Department, 2009, 38(03):44-47.
[7] 阎维平,李皓宇. 三分仓回转式空气预热器传热的数值解法[J]. 动力工程,2009,29(09):841-845. YAN Weiping, LI Haoyu. Numerical method on heat transfer in tri-sectional regenerative air heater[J]. Journal of Power Engineering, 2009, 29(09):841-845.
[8] 张启. 回转式空气预热器温度场数值计算及漏风研究[D].上海:上海交通大学,2009. ZHANG Qi. Numerical calculation of air preheater and study on air leakage[D].Shanghai: Shanghai Jiao Tong University, 2009.
[9] 胡华进,徐治皋. 三分仓空气预热器传热特性的算法研究[J]. 动力工程,1988,18(01):54-57. HU Huajin, XU Zhigao. Research on the calculation of the heat transfer of tri-sectional regenerative air heater [J]. Power Engineering, 1988, 18(01):54-57.
[10] 周俊虎,杨卫娟,靳彦涛,等. 三分仓空气预热器热力计算的研究[J]. 动力工程,2003,23(06):2810-2813. ZHOU Juhu, YANG Weijuan, JIN Yangtao, et al. Study on thermodynamic calculation of tri-section regenerative air preheater[J]. Journal of Power Engineering,2003, 23(06):2810-2813.
[11] 王洪跃,毕小龙,司风琪,等. 求解回转式空气预热器传热模型的解析—数值法[J]. 中国电机工程学报,2006,26(11):51-55. WANG Hongyue, BI Xiaolong, SI Fengqi, et al. Analytical-numerical method based on the model of heat transfer in rotary regenerator[J]. Proceedings of the CSEE, 2006, 26(11):51-55.
[12] 黄景立. 三分仓回转式空气预热器的热力计算方法研究[D]. 北京: 华北电力大学,2007. HUANG Jinli. Research on the thermal analysis of the three sectional regenerative air preheater[D]. Beijing: North China Electric Power University, 2007.
[13] 赵建英,刘长良,曲晓平,等. 三分仓空气预热器链式结构的集总参数模型[J]. 华北电力大学学报,2007,34(02): 134-137. ZHAO Jianying, LIU Changliang, QU Xiaoping, et al. Chain structure modeling method based on lumped-parameter for tri-sectional regenerative air pre-heater[J]. Journal of North China Electric Power University, 2007, 34(02):134-137.
[14] 程芳真, 蒋滋康. 三分仓回转式空气预热器的建模与仿真[J]. 发电设备, 1998(1):9-12. CHENG Fangzhen, JIANG Zikang. Modeling and simulation of tri-section regenerative air preheater[J].Power Equipment, 1998(1):9-12.
[15] 王萍华, 唐必光, 熊立红, 等. 三分仓回转式空气预热器计算机辅助计算[J]. 华中电力,2001,14(04):22-24. WANG Pinghua, TANG Biguang, XIONG Lihong, et al. Computer auxiliary calculation of rotating air-preheater[J]. Central China Electric Power, 2001, 14(04):22-24.
[16] 刘福国,周新刚. 考虑轴向导热的三分仓回转预热器传热模型及验证[J]. 机械工程学报,2010,46(22):144-150. LIU Fuguo, ZHOU Xingang. Heat transfer model of tri-section rotary air preheater and experimental verification[J]. Journal of Mechanical Engineering, 2010, 46(22):144-150.
[17] 李杨, 周元祥, 谢天, 等. 三分仓空气预热器热力计算的简化方法[J]. 动力工程学报, 2013,33(01):37-41. LI Yang, ZHOU Yuanxiang, XIE Tian, et al. A simplified method for heat balance calculation of tri-sectional regenerative air heater[J]. Journal of Chinese Society of Power Engineering, 2013, 33(01):37-41.
[18] 梁海文,邱凤翔,姚学忠,等. 回转式空预器内部温度场的数值计算[J]. 华东电力,2009,37(09):1614-1617. LIANG Haiwen, QIU Fengxiang, YAO Xuezhong, et al. Numerical calculation of inner temperature fields of rotary air preheaters[J]. East China Electric Power, 2009, 37(09):1614-1617.
[19] 冷伟,王渡. 一种改进的回转式空气预热器热力计算方法[J]. 动力工程,2005,25(03):392-395. LENG Wei, WANG Du. An improved way for thermal calculation of rotary air preheaters [J]. Journal of Power Engineering, 2005, 25(03):392-395.
[1] 褚达,史月涛,王晓娟. 四分仓回转空预器热力模型与漏风模型耦合计算[J]. 山东大学学报(工学版), 2016, 46(5): 126-130.
[2] 吕明新1,2,宋固1,董震1,魏露露1, 赖艳华1*. 两级反射线性菲涅尔中高温集热系统热性能[J]. 山东大学学报(工学版), 2013, 43(2): 105-110.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!