JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE) ›› 2012, Vol. 42 ›› Issue (2): 97-101.

• Articles • Previous Articles     Next Articles

Fouling properties of a vibration pipe under the condition of constant heat flux

LIAN Gen-kuan1, TIAN Mao-cheng2, LENG Xue-li2   

  1. 1. Power Department, Institute of State Grid Technology, Taian 271000, China;
    2. Institute of Energy and Power, Shandong University, Jinan 250061, China
  • Received:2011-03-29 Online:2012-04-20 Published:2011-03-29

PDF (PC)

1354

Abstract:

The experiment platform was of the round tube fouling was established. The fouling growth characteristics of the still and vibrational pipes under the condition of constant heat flux were experimentally studied, and the time-dependent curves of fouling resistance under different conditions were obtained. Experimental results showed that the fouling growth curve was representative asymptote,and the asymptotic fouling resistance declined with an increasing vibrational Reynolds number in exponential form,and the vibrational asymptotic fouling resistance was less than the stillness asymptotic fouling resistance under the same conditions. Vibration fouling resistance is significantly reduced while the frequency and amplitude increase.

Key words:  vibration, fouling, thermal resistance, experiment, round tube, Reynolds number, frequency, amplitude

[1] ZHOU Qian, LI Qun, ZHU Dandan, LI Yibo. Coordinated inertia response control for offshore low frequency wind power system based on adaptive virtual inertia of M3C [J]. Journal of Shandong University(Engineering Science), 2025, 55(5): 30-39.
[2] Hengxu ZHANG,Zhimin GAO,Yongji CAO,Hao QIN,Dong YANG,Huan MA. Review and prospect of research on power system inertia with high penetration of renewable energy source [J]. Journal of Shandong University(Engineering Science), 2022, 52(5): 1-13.
[3] Hengxu ZHANG,Yongji CAO,Yi ZHANG,Changgang LI,Jiacheng RUAN,VLADIMIR Terzija. Review of frequency dynamic behavior evolution and analysis method requirements of power system [J]. Journal of Shandong University(Engineering Science), 2021, 51(5): 42-52.
[4] ZHANG Mingcai, JU Guanghong, XIONG Zhangqiang, ZHANG Dazhou. Forward modeling analysis of seismic wave field for TGS360pro advanced prediction of groundwater: taking the karst model as an example [J]. Journal of Shandong University(Engineering Science), 2021, 51(3): 68-75.
[5] . Earth fault protection method based on frequency band power factor [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 76-86.
[6] ZHOU Shuming, YAN Donghuang. Experimental study on stiffness of reinforced concrete pre-cracked beams based on crack parameters [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 53-59.
[7] Xin LIU,Fengling YANG. Vibration characteristics of flexible-blade Rushton impeller [J]. Journal of Shandong University(Engineering Science), 2020, 50(5): 50-55.
[8] ZHANG Hejun, WANG Peng, XU Kai, SHI Fang. Faulty phase and line selection method based on the feature extraction of the phase current in the selected frequency band [J]. Journal of Shandong University(Engineering Science), 2020, 50(5): 99-106.
[9] Guoren LÜ,Jiandong GE,Haitao XIAO. Treatment of coastal soft foundation with cement-soil mixing pile [J]. Journal of Shandong University(Engineering Science), 2020, 50(3): 73-81.
[10] Yu LIU,Shenjie ZHOU,Kanghui WU. Size-dependenct intrinsic properties of the bilayer piezoelectric microbeam [J]. Journal of Shandong University(Engineering Science), 2019, 49(6): 107-112.
[11] Maoyuan ZHANG, Xiangqiang KONG, Yimeng YANG, Xiaodong LIU. Influence of performance of direct-expansion solar-assisted heat pump system at different solar radiation intensity [J]. Journal of Shandong University(Engineering Science), 2019, 49(5): 85-90.
[12] Yajuan XIE,Song YU,Bangxiang LI,Xiang XU,Weishen ZHU. Crack initiation theory and experimental verification of pre-existing plane cracks with seepage pressure [J]. Journal of Shandong University(Engineering Science), 2019, 49(4): 36-43.
[13] Jie LIU, Zhechao WANG, Yupeng ZHANG, Huayang SUN. Flow characteristics of rough rock fractures under wide range of Reynolds numbers [J]. Journal of Shandong University(Engineering Science), 2019, 49(4): 70-77.
[14] MA Chicheng, GUO Zonghe, LIU Canchang, DAI Xiangjun, ZHANG Xinong, MAO Boyong. Dynamics charactersitics of flexible beams undergoing time varying mass [J]. Journal of Shandong University(Engineering Science), 2018, 48(4): 78-87.
[15] QIN Liguo, HE Xiao, ZHOU Donghua. A new distributed formation for multi-agent systems with constant time delays [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(5): 79-88.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] ZHANG Yong-hua,WANG An-ling,LIU Fu-ping . The reflected phase angle of low frequent inhomogeneous[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 22 -25 .
[2] LI Kan . Empolder and implement of the embedded weld control system[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(4): 37 -41 .
[3] KONG Xiang-zhen,LIU Yan-jun,WANG Yong,ZHAO Xiu-hua . Compensation and simulation for the deadband of the pneumatic proportional valve[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(1): 99 -102 .
[4] LAI Xiang . The global domain of attraction for a kind of MKdV equations[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(1): 87 -92 .
[5] YU Jia yuan1, TIAN Jin ting1, ZHU Qiang zhong2. Computational intelligence and its application in psychology[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 1 -5 .
[6] CHEN Rui, LI Hongwei, TIAN Jing. The relationship between the number of magnetic poles and the bearing capacity of radial magnetic bearing[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2018, 48(2): 81 -85 .
[7] WANG Bo,WANG Ning-sheng . Automatic generation and combinatory optimization of disassembly sequence for mechanical-electric assembly[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 52 -57 .
[8] JI Tao,GAO Xu/sup>,SUN Tong-jing,XUE Yong-duan/sup>,XU Bing-yin/sup> . Characteristic analysis of fault generated traveling waves in 10 Kv automatic blocking and continuous power transmission lines[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 111 -116 .
[9] QIN Tong, SUN Fengrong*, WANG Limei, WANG Qinghao, LI Xincai. 3D surface reconstruction using the shape based interpolation guided by maximal discs[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2010, 40(3): 1 -5 .
[10] ZHANG Ying,LANG Yongmei,ZHAO Yuxiao,ZHANG Jianda,QIAO Peng,LI Shanping . Research on technique of aerobic granular sludge cultivationby seeding EGSB anaerobic granular sludge[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(4): 56 -59 .
Copyright 2018 © Editorial office of Journal of Shandong University (Engineering Science)
Supported by Beijing Magtech Co.Ltd