JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE) ›› 2014, Vol. 44 ›› Issue (4): 76-83.doi: 10.6040/j.issn.1672-3961.0.2014.006

Previous Articles     Next Articles

The analysis and testing of thermal performance on solar evacuated tube

ZHANG Tao1, HAN Jitian1, YAN Suying2, YU Zeting1, ZHOU Ran1   

  1. 1. School of Energy and Power Engineering, Shandong University, Jinan 250061, Shandong, China;
    2. College of Energy and Power Engineering, Inner Mongolia University of Technology, Hohhot 010051, Inner Mongolia Municipality, China
  • Received:2014-01-06 Revised:2014-05-08 Published:2014-01-06

PDF (PC)

1585

Abstract: The joint application test bench for solar-thermal photovoltaic was set up to study solar Kalina cycle. The analysis and testing of thermal performance on solar evacuated tube was carried out with methods of experimental and numerical simulation through the experiment platform of single tube solar water heater. The temperature and velocity field of single tube solar water heater were visible analyzed with field synergy principle. The study showed that the two dimensional numerical calculation model could accurately reflect the trend of all-glass evacuated tube solar water heater in the same conditions and the coefficient of field synergy on evacuated tube which was equipped with guide plate was superior to other structures. It was finally confirmed that the Φ58 mm×1 800 mm of solar evacuated tube equipped with reflector and guide plate was the best choice.

Key words: solar Kalina cycle, the single tube solar water heater, strengthen heat transfer, field synergy principle, experimental study, numerical simulation

CLC Number: 

  • TK515
[1] LOIOS P A, ROGDAKIS E D. A kalina power cycle driven by renewable energy sources[J]. Energy, 2009, 34:457-464.
[2] GANESH N S, SRINIVAS T. Design and modeling of low temperature solar thermal power station[J]. Applied Energy, 2012, 91:180-186.
[3] 路岭,严晋跃,马一太,等. Kalina循环放热过程的热力学分析[J].工程热物理学报,1989,10(3):249-251. LU Ling, YAN Jinyue, MA Yitai, et al. Thermodynamic analysis of heat-releasing process of Kalina cycle[J]. Journal of Engineering Thermophysics, 1989, 10(3):249-251.
[4] 吕灿仁,严晋跃,马一太. Kalina循环的研究和开发及其提高效率的分析[J].热能动力工程,1991,6(1):1-7. LV Canren, YAN Jinyue, MA Yitai. The research and development of kalina cycle and an analysis of its efficiency enhancement potentiality[J]. Journal of Engineering for Thermal Energy and Power, 1991, 6(1):1-7.
[5] MORRISON G L, BUDIHARDJO I, BEHNIA M. Measurement and simulation of flow rate in a water-in-glass evacuated tube solar water heater[J]. Solar Energy, 2005, 78:257-267.
[6] ROSENGARTEN G, MORRISON G L, BEHNIA M. Mixed convection in a narrow rectangular cavity with bottom inlet and outlet[J]. International Journal of Heat and Fluid Flow, 2001, 22:168-179.
[7] BUDIHARDJO I, MORRISON G L, BEHNIA M. Natural circulation flow through water-in-glass evacuated tube solar collectors[J]. Solar Energy, 2007, 81:1460-1472.
[8] BUDIHARDJO I, MORRISON G L. Performance of water-in-glass evacuated tube solar water heaters[J]. Solar Energy, 2009, 83:49-56.
[9] FAN Jianhua, SHAH L J, FURBO S. Flow distribution in a solar collector panel with horizontally inclined absorber strips[J]. Solar Energy, 2007, 81:1501-1511.
[10] SHAH L J, FURBO S. Entrance effects in solar storage tanks[J]. Solar Energy, 2003, 75:337-348.
[11] SHAH L J, ANDERSEN E, FURBO S. Theoretical and experimental investigation of inlet stratifiers for solar storage tanks[J]. Applied Thermal Engineering, 2005, 25:2086-2099.
[12] 何梓年.太阳能热利用[M].合肥:中国科学技术大学出版社,2009:1-583.
[13] 何梓年,朱郭志.太阳能供热采暖应用技术手册[M].北京:化学工业出版社,2009:1-302.
[14] 郑瑞澄.民用建筑太阳能热水系统工程技术手册[M].北京:化学工业出版社,2005:1-326.
[15] 刘鉴民.太阳能热动力发电技术[M].北京:化学工业出版社,2012:1-266.
[16] 王志峰,SUN Hongwei.全玻璃真空管空气集热器管内流动与换热的数值模拟[J].太阳能学报,2001,22(1):35-39. WANG Zhifeng, SUN Hongwei. A numerical simulation on heat transfer and fluid flow in a glass tube of all-glass evacuated tubular solar air heater[J]. Acta Energiae Solaris Sinica, 2001, 22(1):35-39.
[17] 王志峰.全玻璃真空管太阳能空气集热器热性能试验方法研究[J].太阳能学报,2001,22(2):141-147. WANG Zhifeng. Study on measurement of thermal performance of all-glass evacuated tubular solar air heater[J]. Acta Energiae Solaris Sinica, 2001, 22(2):141-147.
[18] 艾宁,樊建华,计建炳. CFD-PIV 流场分析技术应用于太阳热水系统的研究进展[J].化工进展,2007,26(4):513-518. AI Ning, FAN Jianhua, JI Jianbing. Overview of CFD and PIV application in investigation of solar thermal systems[J]. Chemical Industry and Engineering Progress, 2007, 26(4):513-518.
[19] 艾宁,樊建华,李育敏. 全玻璃真空管型太阳热水器内流场的 CFD模拟[J].北京航空航天大学学报,2008,34(10):1195-1199. AI Ning, FAN Jianhua, LI Yumin. CFD study of fluid flow in an all-glass evacuated tube solar water heater[J]. Journal of Beijing University of Aeronautics and Astronautics, 2008, 34(10):1195-1199.
[20] 张涛,闫素英,田瑞,等.全玻璃真空管太阳热水器数值模拟研究[J].可再生能源,2011,29(5):10-14. ZHANG Tao, YAN Suying, TIAN Run, et al. The numerical simulation study of all-glass evacuated tube solar water heater[J]. Renewable Energy Resources, 2011, 29(5):10-14.
[21] 张涛,韩吉田,闫素英,等.全玻璃真空管太阳热水器影响因素的数值模拟研究[J].可再生能源,2012,30(10):1-5. ZHANG Tao, HAN Jitian, YAN Suying, et al. The numerical simulation study on influencing factors in all-glass evacuated tube solar water heater[J]. Renewable Energy Resources, 2012, 30(10):1-5.
[22] 王福军.计算流体动力学分析—CFD软件原理与应用[M].北京:清华大学出版社,2004:1-23.
[23] 温正,石良辰,任毅如.FLUENT流体计算应用教程[M].北京:清华大学出版社,2009:53-105.
[24] 过增元.场协同原理与强化传热新技术[M].北京:中国电力出版社,2004:1-290.
[25] 李志信,过增元.对流传热优化的场协同理论[M].北京:科学出版社,2010:1-360.
[1] LIU Qiming, WANG Wenhui, PAN Yingnan, GAO Yaohui, ZHENG Chengcheng, HE Peng. Influence of thickness defects on the stability of the primary support structure and risk assessment [J]. Journal of Shandong University(Engineering Science), 2025, 55(5): 165-178.
[2] Yuxin WANG,Sizhong LÜ,Wang YAO,Chunjin LIN,Ming ZHANG,Zhaofeng LI,Jian ZHANG,Yansheng WANG. Parameter design and effect evaluation of pile side splitting grouting insilty clay stratum [J]. Journal of Shandong University(Engineering Science), 2023, 53(6): 70-81.
[3] Pengning GUO,Wei LIU,Hao YUAN,Shuo FENG,Yangang WANG. Analysis of screw extrusion dehydration efficiency based on micro element discrete model [J]. Journal of Shandong University(Engineering Science), 2023, 53(1): 114-121.
[4] Yiming ZHANG,Yunpeng LI,Jing LI,Junyu CONG. Development of numerical calculation for coupled multi-field problems in cracked/porous media [J]. Journal of Shandong University(Engineering Science), 2022, 52(6): 63-78.
[5] Weiqin ZHENG,Jie XU,Jie SUN,Ke WU. Mechanical characteristics of TBM tunnel segment in composite stratum [J]. Journal of Shandong University(Engineering Science), 2022, 52(4): 210-213.
[6] TIAN Li,Wenzhe BI,Sarim Saleem SIDDIQUI,Kaiyue LIU. Review on structural resistance to downburst wind loads [J]. Journal of Shandong University(Engineering Science), 2021, 51(5): 32-41.
[7] LU Guangzhao, ZHOU Bo, XU Feng, SHANGGUAN Wei, WANG Gang, ZHANG Shubo. Stability analysis and construction mechanics of shallow buried bias tunnel openings [J]. Journal of Shandong University(Engineering Science), 2021, 51(4): 61-70.
[8] WANG Chunguo. Optimization of ventilation system of TBM tunnel construction and evaluation of dust suppression effect [J]. Journal of Shandong University(Engineering Science), 2021, 51(3): 52-60.
[9] Chunguo WANG. Study on full face hard rock tunnel boring machine through the overpass in composite stratum [J]. Journal of Shandong University(Engineering Science), 2021, 51(3): 45-51.
[10] SUN Jie, WU Ke, ZHENG Yang, LI Shuchen, YUAN Chao, WANG Xiuwei. Influence of TBM tunnel excavation at different positions on buildings [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 32-38.
[11] SU Sibo, WANG Guoqing, JIA Xianzhuo, LI Zhicong, HUANG Zhigang. Influence of shear span ratio on seismic performance of hollow pipe pier with slot connection [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 39-45.
[12] ZHOU Shuming, YAN Donghuang. Experimental study on stiffness of reinforced concrete pre-cracked beams based on crack parameters [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 53-59.
[13] XU Zaigen, LIU Zhengwei, LIU Wenpeng, ZHOU Mengyao, LIU Juncai, TIAN Li. Calculation method of the single-double angle joints in transmission towers [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 87-93.
[14] CHEN Yucheng, WANG Zhaoyang, GUO Ming, LIN Peng. Influence of concealed karst cave on surrounding rock stability and its treatment technology [J]. Journal of Shandong University(Engineering Science), 2020, 50(5): 33-43.
[15] Jinsheng QI, Hongzhen CAO, Yan SHI, Wenjing DU, Zhan WANG. Optimization of the inner deflector of the shrimp-waist elbow [J]. Journal of Shandong University(Engineering Science), 2020, 50(5): 64-69.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] WANG Su-yu,<\sup>,AI Xing<\sup>,ZHAO Jun<\sup>,LI Zuo-li<\sup>,LIU Zeng-wen<\sup> . Milling force prediction model for highspeed end milling 3Cr2Mo steel[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(1): 1 -5 .
[2] ZHANG Yong-hua,WANG An-ling,LIU Fu-ping . The reflected phase angle of low frequent inhomogeneous[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 22 -25 .
[3] LI Kan . Empolder and implement of the embedded weld control system[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(4): 37 -41 .
[4] KONG Xiang-zhen,LIU Yan-jun,WANG Yong,ZHAO Xiu-hua . Compensation and simulation for the deadband of the pneumatic proportional valve[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(1): 99 -102 .
[5] LAI Xiang . The global domain of attraction for a kind of MKdV equations[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(1): 87 -92 .
[6] YU Jia yuan1, TIAN Jin ting1, ZHU Qiang zhong2. Computational intelligence and its application in psychology[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 1 -5 .
[7] CHEN Rui, LI Hongwei, TIAN Jing. The relationship between the number of magnetic poles and the bearing capacity of radial magnetic bearing[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2018, 48(2): 81 -85 .
[8] LI Ke,LIU Chang-chun,LI Tong-lei . Medical registration approach using improved maximization of mutual information[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 107 -110 .
[9] JI Tao,GAO Xu/sup>,SUN Tong-jing,XUE Yong-duan/sup>,XU Bing-yin/sup> . Characteristic analysis of fault generated traveling waves in 10 Kv automatic blocking and continuous power transmission lines[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 111 -116 .
[10] . [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 27 -32 .
Copyright 2018 © Editorial office of Journal of Shandong University (Engineering Science)
Supported by Beijing Magtech Co.Ltd