Journal of Shandong University(Engineering Science) ›› 2020, Vol. 50 ›› Issue (6): 92-100.doi: 10.6040/j.issn.1672-3961.0.2020.277

Previous Articles     Next Articles

Analysis of pipe roof grouting reinforcement effect at tunnel entrance in loose stratum

YU Jun1, WENG Xianjie2, FAN Wensheng3, ZHANG Lianzhen4   

  1. 1. Jiangxi Province Traffic Construction Engineering Quality Supervision Administration, Nanchang 330008, Jiangxi, China;
    2. Jiangxi Traffic Consulting Company, Nanchang 330008, Jiangxi, China;
    3. Yichun Management Center, Jiangxi Provincial Expressway Investment Group Co., Ltd, Yichun 336000, Jiangxi, China;
    4. College of Pipeline and Civil Engineering, China University of Petroleum, Qingdao 266580, Shandong, China
  • Published:2020-12-15

PDF (PC)

411

Abstract: Based on Lianhua Tunnel in Pinglian Express Way, three-dimensional calculation model was established to study excavation stability considering pipe roof grouting reinforcement effect. Effect of different pipe roof grouting parameters on excavation stability was analyzed quantitatively, such as mechanical parameters of grouted body, pipe roof interval, grouting radius. In the end, numerical simulation results were used and verified in engineering project. Research results showed that there existed plastic failure zone at vault and region below tunnel face. Pipe roof grouting method had effect on limiting deformation of surrounding rock, reducing volume strain of surrounding rock and cutting off connection between plastic failure zone on vault and tunnel. In whole affected area of pipe roof grouting, maximum settlement of pipe roof settlement appeared around tunnel face. Maximum settlement of pipe roof settlement was negatively related with elastic modulus of grouted body and grouting radius, positively related with pipe roof interval. However, influence level of pipe roof interval was lower than elastic modulus of grouted body or grouting radius.

Key words: rock and soil mechanics, loose stratum, tunnel, pipe roof grouting, reinforcement effect

CLC Number: 

  • TU45
[1] 李术才,张伟杰,张庆松,等. 富水断裂带优势劈裂注浆机制及注浆控制方法研究[J]. 岩土力学, 2014,35(3): 744-752. LI Shucai, ZHANG Weijie, ZHANG Qingsong, et al. Research on advantage-fracture grouting mechanism and controlled grouting method in water-rich fault zone[J]. Rock and Soil Mechanics, 2014, 35(3):744-752.
[2] 张伟杰,李术才,魏久传,等. 富水破碎岩体帷幕注浆模型试验研究[J]. 岩土工程学报, 2015, 37(9): 1627-1634. ZHANG Weijie, LI Shucai, WEI Jiuchuan, et al. Model tests on curtain grouting in water-rich broken rock mass[J]. Chinese Journal of Geotechnical Engineering, 2015, 37(9): 1627-1634.
[3] 钱七虎. 地下工程建设安全面临的挑战与对策[J]. 岩石力学与工程学报, 2012, 31(10): 1945-1956. QIAN Qihu. Challenges faced by underground projects construction safety and countermeasures[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(10): 1945-1956.
[4] 耿大新,石钰锋,阳军生,等. 浅覆大断面隧道长大管棚超前支护受力研究[J]. 华中科技大学学报(自然科学版), 2016, 44(6): 98-103. GENG Daxin, SHI Yufeng, YANG Junsheng, et al. Research on forepoling force of long and large pipe roof for shallow tunnel large section under existing highway[J]. Journal of Huazhong University of Science and Technology.(Natural Science Edition), 2016, 44(6): 98-103.
[5] 伍振志,傅志锋,王静,等. 浅埋松软地层开挖中管棚注浆法的加固机理及效果分析[J]. 岩石力学与工程学报, 2005, 24(6): 1025-1029. WU Zhenzhi, FU Zhifeng, WANG Jing, et al. Study of support mechanism and effect of shed-pipe grouting technology for tunneling construction in shallow-buried soft stratum[J]. Chinese Journal of Rock Mechanics and Engineering, 2005, 24(6): 1025-1029.
[6] 张龙生,翁贤杰. 富水软弱围岩隧道塌方机理及治理技术研究[J]. 中外公路, 2017, 37(1): 173-179. ZHANG Longsheng, WENG Xianjie. Research on collapse mechanism and control technology of tunnel in water-rich and soft stratum[J]. Journal of China & Foreign Highway, 2017, 37(1): 173-179.
[7] 陈峥,何平,颜杜民,等. 考虑土拱效应的管棚合理间距计算方法[J]. 岩土力学, 2019, 40(5): 1993-2000. CHEN Zheng, HE Ping, YAN Dumin, et al. A method to calculate rational spacing between pipes in pipe roofs considering soil arching effects[J]. Rock and Soil Mechanics, 2019, 40(5): 1993-2000.
[8] 高红杰,何平,陈峥. 深埋非对称连拱隧道过程荷载计算方法研究[J]. 岩土工程学报, 2020, 42(6): 1059-1066. GAO Hongjie, HE Ping, CHEN Zheng. Calculation of process load of deep-buried asymmetric multi-arch tunnels[J]. Chinese Journal of Geotechnical Engineering, 2020, 42(6): 1059-1066.
[9] 满帅,孔超,王海彦. 隧道洞口浅埋段管棚超前支护开挖进尺优化[J]. 铁道标准设计, 2013(10): 108-111. MAN Shuai, KONG Chao, WANG Haiyan. Optimization of Excavation Footage of Shallowly-buried Section of Tunnel Portal Supported by Advance Pipe Roof[J]. Railway Standard Design, 2013(10): 108-111.
[10] 郭璇,张鸿儒,蒙蛟,等. 软弱围岩隧道管棚预支护开挖土压分布模型试验[J]. 岩石力学与工程学报, 2016, 35(6): 1214-1224. GUO Xuan, ZHANG Hongru, MENG Jiao, et al. Model test to earth pressure distribution on pipe roof of tunnels as pre-supporting system in weak surrounding rock[J]. Chinese Journal of Rock Mechanics and Engineering, 2016, 35(6): 1214-1224.
[11] 郭璇,张晓新,王梦恕. 弧形侧向抗力法的力法推导及例证[J]. 岩石力学与工程学报, 2015, 34(增刊2): 4080-4090. GUO Xuan, ZHANG Xiaoxin, WANG Mengshu. Derivation and validation of structural mechanics force method for sinusoidal curve lateral resistance method in tunnelling lining[J]. Chinese Journal of Rock Mechanics and Engineering, 2015, 34(Suppl.2): 4080-4090.
[12] 张明聚,林毅,黄明琦,等. 厦门翔安隧道洞口段管棚设计与施工[J]. 北京工业大学学报, 2007, 33(10): 1056-1059. ZHANG Mingju, LIN Yi, HUANG Mingqi, et al. Degisn and construction of pipe roof at entrance of Ximen Xiangan tunnel[J]. Journal of Beijing University of Technology, 2007, 33(10): 1056-1059.
[13] 孙志杰,申俊敏. 隧道洞口段不同围岩刚度下管棚的支护效果分析[J]. 华北水利水电学院学报, 2013, 34(6): 25-28. SUN Zhijie, SHEN Junmin. Support effect of pipe roof at tunnel entrance at different stiffness of surrounding rock[J]. Journal of North China Institute of Water Conservancy and Hydroelectric Power, 2013, 34(6): 25-28.
[14] 苟德明,阳军生,高世军. 下穿公路连拱隧道双层管棚预加固作用数值分析[J]. 长沙交通学院学报, 2008, 24(2): 16-22. GOU Deming, YANG Junsheng, GAO Shijun. Numerical analysis of pre-reinforcement action about double-layer pipe roof in multi arch tunnel under the existing highway[J]. Journal of Changsha Communications University, 2008, 24(2): 16-22.
[15] 董敏,董明星,阳军生. 下穿既有高速公路下隧道施工双层管棚对土层加固作用有限元数值分析[J]. 公路工程, 2014, 39(3): 284-289. DONG Min, DONG Mingxing, YANG Junsheng. Numerical Analysis of Finite Element for Double-deck Pipe Shed's Reinforcement for Soil Layer in Tunnel Construction under Expressway[J]. Highway Engineering, 2014, 39(3): 284-289.
[16] 钟放平. 下穿既有公路的土江冲隧道双层管棚设计及监测分析[J]. 现代隧道技术, 2007, 44(4): 36-40. ZHONG Fangping. Double-layer pipe roofing design and monitoring for Tujiangchong tunnel under-crossing an existing highway[J]. Modern Tunnelling Technology, 2007, 44(4): 36-40.
[1] Yuxin WANG,Sizhong LÜ,Wang YAO,Chunjin LIN,Ming ZHANG,Zhaofeng LI,Jian ZHANG,Yansheng WANG. Parameter design and effect evaluation of pile side splitting grouting insilty clay stratum [J]. Journal of Shandong University(Engineering Science), 2023, 53(6): 70-81.
[2] Wenbin XIAO,Yinbiao XIE,Yang ZHENG,Ke WU,Rong CHEN,Qiulei LI,Ruizhe CHENG. Deformation failure and damage evolution of urban metro tunnels under active faults [J]. Journal of Shandong University(Engineering Science), 2023, 53(3): 1-13.
[3] Weiqin ZHENG,Jie XU,Jie SUN,Ke WU. Mechanical characteristics of TBM tunnel segment in composite stratum [J]. Journal of Shandong University(Engineering Science), 2022, 52(4): 210-213.
[4] Li TIAN,Laiyi ZHANG,Yanming WANG,Juncai LIU. Research progress of building structure under typhoon [J]. Journal of Shandong University(Engineering Science), 2022, 52(1): 28-38.
[5] TIAN Li,Wenzhe BI,Sarim Saleem SIDDIQUI,Kaiyue LIU. Review on structural resistance to downburst wind loads [J]. Journal of Shandong University(Engineering Science), 2021, 51(5): 32-41.
[6] LU Guangzhao, ZHOU Bo, XU Feng, SHANGGUAN Wei, WANG Gang, ZHANG Shubo. Stability analysis and construction mechanics of shallow buried bias tunnel openings [J]. Journal of Shandong University(Engineering Science), 2021, 51(4): 61-70.
[7] WANG Chunguo. Optimization of ventilation system of TBM tunnel construction and evaluation of dust suppression effect [J]. Journal of Shandong University(Engineering Science), 2021, 51(3): 52-60.
[8] Chunguo WANG. Study on full face hard rock tunnel boring machine through the overpass in composite stratum [J]. Journal of Shandong University(Engineering Science), 2021, 51(3): 45-51.
[9] SUN Jie, WU Ke, ZHENG Yang, LI Shuchen, YUAN Chao, WANG Xiuwei. Influence of TBM tunnel excavation at different positions on buildings [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 32-38.
[10] LI Lianxiang, ZHANG Qiang, SHI Jinjiang, LIU Jiadian, HOU Yingxue. Law of horizontal deformation displacement of tunnels due to adjacent excavation [J]. Journal of Shandong University(Engineering Science), 2021, 51(1): 46-52.
[11] CHEN Yucheng, WANG Zhaoyang, GUO Ming, LIN Peng. Influence of concealed karst cave on surrounding rock stability and its treatment technology [J]. Journal of Shandong University(Engineering Science), 2020, 50(5): 33-43.
[12] WANG Chunguo. Mechanical behavior of large-span and small spacing road tunnel with biased pressure [J]. Journal of Shandong University(Engineering Science), 2020, 50(4): 85-89.
[13] SHI Xuesong, GUAN Qingzheng, WANG Wenyang, XU Zhenhao, LIN Peng, WANG Xiaote, LIU Jie. Numerical simulation of rock fragmentation process by TBM cutter in double-joint rock mass [J]. Journal of Shandong University(Engineering Science), 2020, 50(4): 70-79.
[14] Mingcai LIU. Impact analysis on construction of large section and small spacing road tunnel [J]. Journal of Shandong University(Engineering Science), 2019, 49(4): 78-85.
[15] ZHOU Chenying. Image analysis and engineering application of ground penetrating radar in tunnel lining detection [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2018, 48(4): 61-68.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] LI Kan . Empolder and implement of the embedded weld control system[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(4): 37 -41 .
[2] LAI Xiang . The global domain of attraction for a kind of MKdV equations[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(1): 87 -92 .
[3] YU Jia yuan1, TIAN Jin ting1, ZHU Qiang zhong2. Computational intelligence and its application in psychology[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 1 -5 .
[4] CHEN Rui, LI Hongwei, TIAN Jing. The relationship between the number of magnetic poles and the bearing capacity of radial magnetic bearing[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2018, 48(2): 81 -85 .
[5] WANG Bo,WANG Ning-sheng . Automatic generation and combinatory optimization of disassembly sequence for mechanical-electric assembly[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(2): 52 -57 .
[6] ZHANG Ying,LANG Yongmei,ZHAO Yuxiao,ZHANG Jianda,QIAO Peng,LI Shanping . Research on technique of aerobic granular sludge cultivationby seeding EGSB anaerobic granular sludge[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(4): 56 -59 .
[7] WANG Li-ju,HUANG Qi-cheng,WANG Zhao-xu . [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(6): 51 -56 .
[8] Yue Khing Toh1， XIAO Wendong2， XIE Lihua1. Wireless sensor network for distributed target tracking: practices via real test bed development[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 50 -56 .
[9] SUN Weiwei， WANG Yuzhen. Finite gain stabilization of singlemachine infinite bus system subject to saturation[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 69 -76 .
[10] SUN Yu-li,LI De-fa,ZUO Dun-wen,QI mei . [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2006, 36(6): 19 -23 .
Copyright 2018 © Editorial office of Journal of Shandong University (Engineering Science)
Supported by Beijing Magtech Co.Ltd