您的位置：山东大学 -> 科技期刊社 -> 《山东大学学报（工学版）》

山东大学学报 (工学版) ›› 2020, Vol. 50 ›› Issue (5): 20-25.doi: 10.6040/j.issn.1672-3961.0.2019.746

• • 上一篇    下一篇

砂土介质中颗粒浆液扩散距离变化规律

冯啸1,夏冲1,王凤刚2,张兵2   

  1. 1. 山东建筑大学交通工程学院, 山东 济南 250101;2. 济南力稳岩土工程有限公司, 山东 济南 250101
  • 发布日期:2020-10-19
  • 作者简介:冯啸(1988— ),男,山东潍坊人,讲师,博士,主要研究方向为隧道与地下工程灾害防控. E-mail:FENG_Xiao902@163.com
  • 基金资助:
    山东建筑大学博士基金资助项目(X19018Z)

Variation of granular slurry diffusion distance in sand medium

FENG Xiao1, XIA Chong1, WANG Fenggang2, ZHANG Bing2   

  1. 1. School of Transportation Engineering, Shandong Jianzhu University, Jinan 250101, Shandong, China;
    2. Jinan Liwen Geotechnical Engineering Co., Ltd., Jinan 250101, Shandong, China
  • Published:2020-10-19

PDF (PC)

488

摘要： 基于质量守恒方程、线性滤过定律、Darcy定律及边界条件,建立层流条件下颗粒浆液扩散距离的理论模型。采用自主研发的单体组配式渗透注浆装置,研究不同水灰比、不同流速条件下浆液扩散距离的变化规律,并将忽略渗滤理论值、考虑渗滤理论值、模型试验值进行比对分析。结果表明,恒定流速v0条件下,忽略渗滤效应的浆液扩散距离与实际不相符;浆液水灰比、注浆流速均与扩散距离呈正相关。水灰质量比1∶1时,模型试验值与考虑渗滤理论值偏差18.4~20.8 cm,偏差率68.9%~71.9%;水灰质量比2〓∶1时,模型试验值与考虑渗滤理论值偏差20.7~23.4 cm,偏差率27.0%~28.2%。研究成果可指导注浆钻孔间距设计,具有一定的工程应用价值。

关键词: 砂土层, 颗粒浆液, 渗透注浆, 渗滤效应, 扩散距离

Abstract: Based on the mass conservation equation, linear filtration law, Darcy's law and specific boundary conditions, a theoretical diffusion distance model of granular slurry under laminar flow conditions was established. By developing and applying an assembly-type device for permeating grouting, the diffusion rules of grout under different water-cement ratio and flow rate were studied. The value of model test was compared with the theoretical values when the filtration effect was considered or not. The results showed that when the flow velocity v0 was constant, the theoretical diffusion distance without filtration effect considered was not consistent with reality. Both the water-cement ratio and velocity of grout were positively correlated with diffusion distance. When the water-cement ratio was 1∶1, the deviation between the value of model test and the theoretical calculation with filtration considered was 18.4 to 20.8 cm, with a deviation rate of 68.9% to 71.9%. When the water-cement ratio came to 2 ∶1, corresponding values were within 20.7 to 23.4 cm, and 27.0% to 28.2% respectively. The research results could guide the drilling spacing design of grouting and had some application value for project.

Key words: sand layer, granular slurry, osmotic grouting, filtration effect, diffusion distance

中图分类号: 

  • TU581
[1] 王梦恕. 中国隧道及地下工程修建技术[M]. 北京:人民交通出版社, 2010.
[2] 钱七虎. 地下工程建设安全面临的挑战与对策[J]. 岩石力学与工程学报, 2012, 31(10): 1945-1956. QIAN Qihu. Challenges faced by underground projects construction safety and countermeasures[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(10): 1945-1956.
[3] 冯啸, 李术才, 刘人太, 等. 考虑渗滤效应的水泥浆锋面扩散理论及试验研究[J]. 中国科学(技术科学), 2017, 47(11): 1198-1206. FENG Xiao, LI Shucai, LIU Rentai, et al. Theoretical and experimental research on the grout fronts diffusion considering filtration effect[J]. Scientia Sinica Technologica, 2017, 47(11): 1198-1206.
[4] 《中国公路学报》编辑部. 中国交通工程学术研究综述·2016[J]. 中国公路学报, 2016, 29(6): 1-161. Editorial Department of China Journal of Highway and Transport. Review on China's traffic engineering research progress·2016[J]. China Journal of Highway and Transport, 2016, 29(6): 1-161.
[5] AFSHIN Kordnaeij, REZA Ziaie Moayed, MAJID Soleimani. Unconfined compressive strength of loose sandy soils grouted with zeolite and cement[J]. Soils and Foundations, 2019, 59(4): 905-919.
[6] 冯啸, 刘人太, 李术才, 等. 考虑深层渗滤效应的水泥浆锋面特征研究[J]. 岩石力学与工程学报, 2016, 35(5): 1000-1008. FENG Xiao, LIU Rentai, LI Shucai, et al. Characteristics of moving interface of grout considering deep bed filtration[J]. Chinese Journal of Rock Mechanics and Engineering, 2016, 35(5): 1000-1008.
[7] RAHMAN M, HAKANSSON U, WIKLUND J. In-line rheological measurements of cement grouts: effects of water/cement ratio and hydration[J]. Tunnelling and Underground Space Technology, 2015, 45(1): 34-42.
[8] 刘人太, 冯啸, 李术才, 等. 砂土介质中浆液锋面扩散规律及工程应用研究[J]. 应用基础与工程科学学报, 2018, 26(1): 200-213. LIU Rentai, FENG Xiao, LI Shucai, et al. Study on spreading law of grout dynamic interface in porous medium and its engineering application[J]. Journal of Basic Science and Engineering, 2018, 26(1): 200-213.
[9] 李志鹏. 断层软弱介质注浆扩散加固机理及工程应用[D]. 济南: 山东大学, 2015. LI Zhipeng. Mechanism of grouting spread and reinforcement on soft medium in fault and its application[D]. Jinan: Shandong University, 2015.
[10] FAN Jenchen, LIU Wenyao, TAN Yunwei, et al. Evaluating permeability and efficiency of substrates by using permeation grouting sand column test[J]. KSCE Journal of Civil Engineering, 2018, 22(8): 2843-2855.
[11] 李术才, 冯啸, 刘人太, 等. 考虑渗滤效应的砂土介质注浆扩散规律研究[J]. 岩土力学, 2017, 38(4): 925-933. LI Shucai, FENG Xiao, LIU Rentai, et al. Diffusion of grouting cement in sandy soil considering filtration effect[J]. Rock and Soil Mechanics, 2017, 38(4): 925-933.
[12] 毛家骅. 基于渗滤效应的盾构隧道壁后注浆浆液扩散机理研究[D]. 西安:长安大学,2016. MAO Jiahua. Study on the grouts diffusion mechanism of shield tunnelback-filled grouts based on filtration[D]. Xi'an: Chang'an University, 2016.
[13] 蔡德国, 叶飞, 曹凯, 等. 砂性地层盾构隧道壁后注浆浆液扩散室内试验[J]. 中国公路学报, 2018, 31(10): 274-283. CAI Deguo, YE Fei, CAO Kai, et al. Test of grout diffusion of shield tunnel backfill grouting in sandy strata[J]. China Journal of Highway and Transport, 2018, 31(10): 274-283.
[14] 崔溦,李永杰,戚蓝,等. 高自生热材料注浆过程多场耦合数值分析[J]. 武汉大学学报(工学版), 2018, 51(11): 941-949. CUI Wei, LI Yongjie, QI Lan, et al. Numerical analysis of multifield coupling in high self heating material grouting process[J]. Engineering Journal of Wuhan University, 2018, 51(11): 941-949.
[15] 张连震. 地铁穿越砂层注浆扩散与加固机理及工程应用[D]. 济南: 山东大学, 2017. ZHANG Lianzhen. Study on penetration and reinforcement mechanism of grouting in sand layer disclosed by subway tunnel and its application[D]. Jinan: Shandong University, 2017.
[16] 舒瑶, 季昌, 周顺华, 等. 考虑地层渗透性的盾构隧道施工期管片上浮预测[J]. 岩石力学与工程学报, 2017, 36(增刊1): 3516-3524. SHU Yao, JI Chang, ZHOU Shunhua, et al. Prediction for shield tunnel segment uplift considering the effect of stratum permeability[J]. Chinese Journal of Rock Mechanics and Engineering, 2017, 36(Suppl.1): 3516-3524.
[17] DOMINIQUE J Tobler, ERICA Maclachlan, VERNONR Phoenix. Microbially mediated plugging of porous media and the impact of differing injection strategies[J]. Ecological Engineering, 2012, 42: 270-278.
[18] ALMIR Draganovic, HAKAN Stille. Filtration of cement-based grouts measured using a long slot[J]. Tunnelling and Underground Space Technology, 2014, 43: 101-112.
[19] 孔祥言. 高等渗流力学[M]. 合肥: 中国科学技术大学出版社, 2010.
[20] MAGHOUS S, SAADA Z, DORMIEUX L. A model for in situ grouting with account for particle filtration[J]. Computers and Geotechnics, 2007, 34: 164-174.
[21] HERZIG J P, LECLERC D M, GOFF P LE. Flow of Suspensions through porous media-new differential equation for clogged beds is derived[J]. Industrial and Engineering Chemistry, 1970, 62(5): 8-35.
[22] 仵彦卿. 多孔介质渗流与污染物迁移数学模型[M]. 北京: 科学出版社, 2012.
[1] 夏冲,李传贵,冯啸,赵宏魁,张思峰,武剑峰. 水泥粉煤灰-改性水玻璃注浆材料试验研究与应用[J]. 山东大学学报 (工学版), 2022, 52(1): 66-73.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] 陈瑞,李红伟,田靖. 磁极数对径向磁轴承承载力的影响[J]. 山东大学学报(工学版), 2018, 48(2): 81 -85 .
[2] 刘新1 ，宋思利1 ，王新洪2 . 石墨配比对钨极氩弧熔敷层TiC增强相含量及分布形态的影响[J]. 山东大学学报(工学版), 2009, 39(2): 98 -100 .
[3] 郑桂兰,关瑞芳,隋　肃,李建权,李国忠 . 反应型反光型道路标线涂料识别效果研究[J]. 山东大学学报(工学版), 2007, 37(1): 86 -89 .
[4] 徐奴文 唐春安 周济芳 唐烈先 梁正召. 锦屏二级水电站施工排水洞岩爆数值模拟[J]. 山东大学学报(工学版), 2009, 39(4): 134 -139 .
[5] 李贻斌,阮久宏,刘鲁源,宋 锐,荣学文 . 车辆纵向加速度自抗扰控制研究[J]. 山东大学学报(工学版), 2008, 38(4): 1 -04 .
[6] 牛秀明,傅春华 . 炭在脉冲放电过程中对污水中有机物的降解作用[J]. 山东大学学报(工学版), 2008, 38(1): 121 -126 .
[7] 张承慧,裴荣辉,石庆升,马永庆 . 城市变频调速给水泵站的优化配置[J]. 山东大学学报(工学版), 2007, 37(2): 97 -102 .
[8] 邱道宏1,张乐文1,崔伟2,苏茂鑫1,孙怀凤1. 基于趋势检查法的遗传神经网络模型及工程应用[J]. 山东大学学报(工学版), 2010, 40(3): 113 -118 .
[9] 蔡英1, 王刚2*. 一种基于AR模型的非线性盲源提取方法及其应用[J]. 山东大学学报(工学版), 2010, 40(5): 17 -23 .
[10] 赵冠琳,邹增大,王新洪,杜宝帅 . 激光熔覆原位自生TiC-VC复合增强铁基合金层的研究[J]. 山东大学学报(工学版), 2008, 38(2): 6 -9 .
版权所有 © 2018 《山东大学学报(工学版)》编辑部　
地址: 济南市山大南路27号（250100）　 电话: 0531-88366735　 E-mail: xbgxb@sdu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发