Journal of Shandong University(Engineering Science) ›› 2019, Vol. 49 ›› Issue (5): 58-63.doi: 10.6040/j.issn.1672-3961.0.2019.155

• Energy and Power Engineering—Special Topic on Refrigeration Technology • Previous Articles     Next Articles

Performance analysis for an absorption refrigeration system driven by parabolic trough solar collector

Tongtong WANG1(),Jianan SUN1,Tao ZHANG2,Zeting YU1,*(),Jiqiang YIN1   

  1. 1. School of Energy and Power Engineering, Shandong University, Jinan 250061, Shandong, China
    2. Shandong Electric Power Engineering Consulting Institute Co., Ltd, Jinan 250013, Shandong, China
  • Received:2019-04-11 Online:2019-10-20 Published:2019-10-18
  • Contact: Zeting YU E-mail:201744126@mail.sdu.edu.cn;yuzt@sdu.edu.cn
  • Supported by:
    国家自然科学基金资助项目(61733010);山东省自然科学基金资助项目(ZR2019MEE045)

RichHTML

20

PDF (PC)

837

Abstract:

In order to make rational use of solar energy, enhance the seasonal adaptability of the refrigeration system, a medium temperature solar driven ammonia water absorption refrigeration system was proposed. Based on the parabolic trough solar collector (PTSC) driven ammonia single-effect absorption refrigeration system, according to the laws of thermodynamics and the energy balance equation, under the engineering equation solver (ESS), the solar collector model and the refrigeration system model were established respectively, and the key parameters of the system were calculated. The effects of system high pressure, system low pressure, evaporator outlet temperature and rectifier outlet mass fraction on the system were analyzed from three aspects: refrigeration capacity, rectification heat and coefficient of performance (COP). The results showed that the cooling capacity decreased with the increase of the system low pressure; the rectification heat and COP increased with the increasing of the system low pressure; when the outlet temperature of the evaporator rised, the cooling capacity and COP increased; when the rectifier mass fraction increased from 0.977 to 0.999, the COP showed a maximum when the ammonia mass fraction was 0.992. The results provided a theoretical basis for the feasibility of the single-stage absorption refrigeration cycle driven by solar energy.

Key words: solar energy, parabolic trough solar collector, ammonia-water, refrigeration system, COP

CLC Number: 

  • TM911

Fig.1

Schematic diagram of PTSC-driven ammonia absorptionrefrigeration system"

Table 1

System input parameters"

环境温度/℃ 环境压力/MPa IAM PTSC开口宽度/m PTSC长度/m 工质流速/(kg·h-1) 单个集热器模块面积/m2 集热器模块数量/个 吸收器出口温度/℃ 泵等熵效率/%
20 0.1 0.93 2.3 22.54 1 200 30 4 40.1 80

Table 2

Solar collector calculation results"

集热管出口温度/K 槽式聚光镜吸收的太阳能/(W·m-1) 集热管能量损失/(W·m-1) 集热器模块间压降/kPa 太阳能集热器效率/% 支架能量损失/kW 玻璃管能量损失/kW
369.84 1 040 117.9 0.567 42.43 43.029 20.81

Table 3

Calculation results of points in the refrigeration cycle"

状态点 压力/MPa 温度/K ω(氨)/% 焓/(kJ·kg-1) 熵/(kJ·K-1)
1 0.288 313.1 0.397 50.0 0.461
2 1.555 313.2 0.397 48.8 0.460
3 1.555 397.2 0.297 358.0 1.562
4 0.280 350.0 0.297 358.0 1.617
5 1.555 374.9 0.958 1516.0 4.811
6 1.555 374.9 0.397 229.4 1.270
7 1.555 317.6 0.999 129 8 4.184
8 1.555 313.1 0.999 190.4 0.658
9 0.288 262.9 0.999 190.4 0.735
10 0.288 278.1 0.999 1293.0 4.907

Fig.2

Effect of system low voltage on refrigeration system"

Fig.3

Effect of system high pressure on refrigeration system"

Fig.4

Effect of evaporator outlet temperature onrefrigeration system"

Fig.5

Effect of rectifier outlet concentration onrefrigeration system"

1 高志超.抛物槽式太阳能集热技术系统集成研究[D].北京:中国科学院大学, 2011.
GAO Zhichao. Research on system integration of parabolic trench solar collecting technology[D]. Beijing: University of Chinese Academy of Sciences, 2011.
2 包天舒.氨水吸收式制冷系统的实验研究和热经济分析[D].北京:北京化工大学, 2005.
BAO Tianshu. Experimental study and thermal economic analysis of ammonia water absorption refrigeration system[D]. Beijing: Beijing University of Chemical Technology, 2005.
3 陈小砖, 柳建华, 张良, 等. 氨水吸收式制冷系统及关键设备的研究综述[J]. 低温与超导, 2013, 41 (6): 47- 51.
doi: 10.3969/j.issn.1001-7100.2013.06.011
CHEN Xiaozhuan , LIU Jianhua , ZHANG Liang , et al. Summary of research on ammonia water absorption refrigeration system and key equipment[J]. Low Temperature and Superconductivity, 2013, 41 (6): 47- 51.
doi: 10.3969/j.issn.1001-7100.2013.06.011
4 鲍鹤玲, 杨思文. 氨水吸收压缩制冷系统的研究[J]. 流体工程, 1987, (6): 57- 65.
BAO Heling , YANG Siwen . Study on ammonia water absorption compression refrigeration system[J]. Fluid Machinery, 1987, (6): 57- 65.
5 王政航.槽式太阳能聚光集热器集热性能研究[D].武汉:华中科技大学, 2015.
WANG Zhenghang. Research on the performance of parabolic trough solar collector[D]. Wuhan: Huazhong University of Science and Technology, 2015.
6 仇秋玲.一种槽式太阳能聚光集热器的热性能实验研究[D].南京:东南大学, 2016.
QIU Qiuling. Experimental research on thermal performance of a through solar collector[D]. Nanjing: Southeast University, 2016.
7 李程, 王如竹, 王丽伟, 等. 不同驱动温度下间歇性太阳能吸附制冰机的实验研究[J]. 化工学报, 2010, 61 (增刊2): 112- 115.
LI Cheng , WANG Ruzhu , WANG Liwei , et al. Experimental investigation on intermittent solar powered adsorption ice maker driven by different temperatures[J]. Ciesc Journal, 2010, 61 (Suppl.2): 112- 115.
8 王修彦, 韩露. 槽式太阳能聚光集热器传热数学模型研究[J]. 节能技术, 2017, 35 (2): 103- 107.
doi: 10.3969/j.issn.1002-6339.2017.02.002
WANG Xiuyan , HAN Lu . Research on heat transfer mathematic model of parabolic trough solar collector[J]. Energy Conservation Technology, 2017, 35 (2): 103- 107.
doi: 10.3969/j.issn.1002-6339.2017.02.002
9 赵婷, 韩巍, 孙流莉, 等. 中温太阳能驱动的分布式功冷联产系统[J]. 工程热物理学报, 2017, 35 (10): 1793- 1798.
ZHAO Ting , HAN Wei , SUN Liuli , et al. Medium temperature solar driven distributed power cooling cogeneration system[J]. Journal of Engineering Thermophysics, 2017, 35 (10): 1793- 1798.
10 WANG R Z , OLIVEIRA R G . Adsorption refrigeration: an efficient way to make good use of waste heat and solar energy[J]. Progress in Energy & Combustion Science, 2006, 32 (4): 424- 458.
11 戴雨辰, 陈飞, 李宏顺, 等. 太阳能驱动的冷热电联供系统研究进展[J]. 武汉工程大学学报, 2015, 37 (9): 68- 78.
doi: 10.3969/j.issn.1674-2869.2015.09.012
DAI Yuchen , CHEN Fei , LI Hongshun , et al. Research progress on solar-powered cogeneration system[J]. Journal of Wuhan Institute of Technology, 2015, 37 (9): 68- 78.
doi: 10.3969/j.issn.1674-2869.2015.09.012
12 陆至羚, 柳建华, 张良, 等. 氨水吸收式制冷系统性能模拟分析[J]. 制冷技术, 2016, 36 (2): 16- 20.
doi: 10.3969/j.issn.2095-4468.2016.02.004
LU Zhiling , LIU Jianhua , ZHANG Liang , et al. Simulation analysis of performance of ammonia absorption refrigeration system[J]. Refrigeration Technology, 2016, 36 (2): 16- 20.
doi: 10.3969/j.issn.2095-4468.2016.02.004
13 孟欣, 栗鹏飞. 工业余热氨水吸收式制冷系统优化研究[J]. 节能, 2016, 35 (6): 55- 583.
doi: 10.3969/j.issn.1673-6478.2016.06.018
MENG Xin , LI Pengfei . Optimization of industrial waste heat ammonia absorption refrigeration system[J]. Energy Conservation, 2016, 35 (6): 55- 583.
doi: 10.3969/j.issn.1673-6478.2016.06.018
14 刘进阳.高效氨水吸收式制冷系统的理论研究及应用[D].南宁:广西大学, 2017.
LIU Jinyang. Theoretical research and application of high efficiency ammonia water absorption refrigeration system[D]. Nanning: Guangxi University, 2017.
15 王金平.槽式太阳能光热电站关键技术及运行特性的研究[D].南京:东南大学, 2017.
WANG Jinping. Study on the key technology and operation characteristics of solar cell thermal power station[D]. Nanjing: Southeast University, 2017.
16 李梦阳, 刘朝阳, 赵明, 等. 太阳能在火电机组热力系统中的集成应用[J]. 能源研究与利用, 2017, (1): 23- 25.
doi: 10.3969/j.issn.1001-5523.2017.01.013
LI Mengyang , LIU Chaoyang , ZHAO Ming , et al. The integrated application of solar energy in thermal system of thermal power plant[J]. Energy Research & Utilization, 2017, (1): 23- 25.
doi: 10.3969/j.issn.1001-5523.2017.01.013
17 陈玉英. 槽式太阳能集热器传热模型及性能分析[J]. 土木建筑与环境工程, 2016, 38 (4): 53- 58.
CHEN Yuying . Heat transfer model and performance analysis of trough solar collector[J]. Journal of Civil, Architectural & Environmental Engineering, 2016, 38 (4): 53- 58.
18 PADILLA R V , DEMIRKYRY G , GOSWAMI D Y , et al. Analysis of power and cooling cogeneration using ammonia-water mixture[J]. Energy, 2010, 35 (12): 4649- 4657.
doi: 10.1016/j.energy.2010.09.042
19 YANG Fubin , HEEJIN CHO , ZHANG Hongguang , et al. Thermoeconomic multi-objective optimization of a dual loop organic Rankine cycle (ORC) for CNG engine waste heat recovery[J]. Applied Energy, 2017, 205 (4): 1100- 1118.
20 ALVARES S G , TREEP C . Simulation of a solar driven aqua-ammonia absorption refrigeration system Part 2: viability for milk cooling at remote Brazilian dairy farms[J]. International Journal of Refrigeration, 1987, 10 (2): 70- 76.
doi: 10.1016/0140-7007(87)90023-5
21 SAID S A M , SPINDLER K , EL-SHAARAWI M A , et al. Design, construction and operation of a solar powered ammonia—water absorption refrigeration system in Saudi Arabia[J]. International Journal of Refrigeration, 2016, 62, 222- 231.
doi: 10.1016/j.ijrefrig.2015.10.026
22 ABU-EIN S Q , FAYYAD S M , MOMANI W , et al. Performance analysis of solar powered absorption refrigeration system[J]. Heat & Mass Transfer, 2009, 46 (2): 137.
23 KHAN M M A , IBRAHIM N I , SAIDUR R , et al. Performance assessment of a solar powered ammonia—water absorption refrigeration system with storage units[J]. Energy Conversion & Management, 2016, 126, 316- 328.
[1] Wensheng LI, Xian WANG, Yuanze MI, Yongji CAO, Xiaoming LIU, Hengxu ZHANG, Zihan LIU. Method for generation planning with the temporal and spatial correlation of wind and solar power [J]. Journal of Shandong University(Engineering Science), 2022, 52(1): 111-119.
[2] Chenhao JIA,Rutao LIU. Toxic effects and mechanisms of oxidative stress induced by modified ultrafine carbon black [J]. Journal of Shandong University(Engineering Science), 2019, 49(3): 120-128.
[3] ZHAO Yanxia, WANG Xizhao. Multipurpose zero watermarking algorithm for color image based on SVD and DCNN [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2018, 48(3): 25-33.
[4] SHI Fang, ZHANG Hengxu, ZHANG Lei. [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(6): 151-156.
[5] ZHAO Zijian, WANG Fang, CHANG Faliang. Survey on medical robot in computer-aided surgery [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(3): 69-78.
[6] LIAN Lu, HAN Xiangsheng, ZHANG Changqiao, YU Ping, WEI Yunhe. Preparation, characterization and performance of drag reduction agent used in pipeline of brine mining and transportation [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(2): 117-122.
[7] ZHOU Lun, LI Shucai, XU Zhenhao, LI Liping, HUANG Xin, HE Shujiang, LI Guohao. Integrated advanced geological prediction technology of tunnel and its engineering application [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2017, 47(2): 55-62.
[8] QIAO Xiaoyan. Automatic recognition method of microscopic image of harmful algae [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2016, 46(3): 1-6.
[9] WANG Lanzhong, MENG Wenjie. Video perceptual encryption algorithm in remote education receiver [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2015, 45(4): 40-44.
[10] SUN Jinqing, ZHOU Fengyu, YANG Yang, TANG Xiangmeng, LIU Zhaoqi. Efficient infrared video encoding based on multiple hardware encoders [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2015, 45(4): 19-24.
[11] LI Fu-gui1,2, HUANG Tian-qiang1,2*, SU Li-chao1,2, SU Wei-feng3. Heterologous video copy-move forgery detection by fusing multiple features [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2013, 43(4): 32-38.
[12] FU Yan-an1, LIU Hai-ying1, MENG Qing-hu1,2*. 3-d shape recovery from vce Image Based on Shading Information [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2012, 42(6): 63-68.
[13] LAI Yan-hua1, WANG Qing-wei1, L Ming-xin1, SHAO Chang-bo2, KONG De-min1. Exergy analysis of the R404A／CO2cascade refrigeration system [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2011, 41(6): 115-121.
[14] ZHANG Bao-liang1, WANG Hong-yun1, QIN Xu-ping1*, ZHAO Fang1, FENG Wei-hong1, GUO BO2. Hofmann degradation of poly(AM／AMPS) in  inverse emulsion and its application in removal of the Cu(II) ion [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2011, 41(1): 126-132.
[15] ZHANG Liang-liang1,2, LI Jian-ping1,2, WANG Yan1,2, CHEN Guo-qiang1,2, LI Zeng-yong1,2*. Assessment of cerebral oxygenation response to vibration in drivers [J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2011, 41(1): 91-94.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] SHI Lai-shun,WAN Zhong-yi . Synthesis and performance evaluation of a novel betaine-type asphalt emulsifier[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(4): 112 -115 .
[2] YU Jia yuan1, TIAN Jin ting1, ZHU Qiang zhong2. Computational intelligence and its application in psychology[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(1): 1 -5 .
[3] HU Tian-liang,LI Peng,ZHANG Cheng-rui,ZUO Yi . Design of a QEP decode counter based on VHDL[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(3): 10 -13 .
[4] XU Li-li,JI Zhong,XIA Ji-mei . The optimum algorithm for the container loading problem with homogeneous cargoes[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(3): 14 -17 .
[5] PAN Duo-tao,LIU Gui-ping,LIU Chang-feng . Screening of microbe producing flocculant and optimizationon its cultural conditions[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2008, 38(3): 99 -103 .
[6] DIAO Yong, TIAN Si-Meng, CAO Zhe-Meng. Geological work method for the construction of the Yichang Wanzhou Railway tunnel in high risk karst areas[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(5): 91 -95 .
[7] DENG Bin,WANG Jiang . Estimating parameters of a neuron model based on chaos synchronization and adaptive control[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2007, 37(5): 19 -23 .
[8] GAO Hou-Lei, TIAN Jia, DU Jiang, WU Zhi-Gang, LIU Chu-Min. Distributed generation—new technology in energy development[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(5): 106 -110 .
[9] WANG Xue-ping,WANG Deng-jie,SUN Ying-ming*,DONG Lei . Application of the nonprism total station in the detection of a highway bridge[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2007, 37(3): 105 -108 .
[10] SHI Wen-Hua, LIU Wei-Dong, SUN Yong-Fu. Research of 1／3 dam breach simulation and personnel evacuation scenario based on digital elevation model DEM in a quake lake[J]. JOURNAL OF SHANDONG UNIVERSITY (ENGINEERING SCIENCE), 2009, 39(5): 144 -148 .
Copyright 2018 © Editorial office of Journal of Shandong University (Engineering Science)
Supported by Beijing Magtech Co.Ltd